Pierce HUSKY 3 - List of Abbreviations

To Next Page

To Previous Page

SAFETY

1-2 / Husky 3 Foam System

1-2. List of Abbreviations

TERM DEFINITION

AFFF Aqueous Film Forming Foam

AR-AFFF Alcohol Resistant Aqueous Film Forming Foam

FFFP Film Forming Fluoro-Protein

GPM Gallons per Minute

LCD Liquid Crystal Display

LED Light Emitting Diode

LPM Liters per Minute

LVDT Linear Variable Displacement Transducer

NFPA National Fire Protection Association

PSI Pounds per Square Inch

RPM Revolutions per Minute

Main Page

Table of Contents5
Foreword9
Purpose of Manual9
Scope9
Customer Assistancei9
Safety11
Introduction11
1-1.1 T O the Owner -O11
1-1.2 Description of11
List of Abbreviations12
General13
Husky 3 Specifications13
Foam Proportioner13
System Capacity13
Discharges13
2-1.4 System Electrical13
Deshydraulicription of Major Hydraulic14
2-1.5 Foam Concentrate14
Description of Major Components14
Hydraulic Drive System14
2-2.1A HYDRAULIC15
2-2.1B HYDRAULIC16
2-2.1C HYDRAULIC17
2-2.1D HYDRAULIC17
2-2.1E HYDRAULIC18
2-2.1F HYDRAULIC18
2-2.2 Foam Supplys19
2-2.2A FOAMC19
2-2.2B FOAMS19
2-2.2C FOAMC20
2-2.2D FOAMS21
2-2.2E FOAMS21
2-2.2F INLINEF22
2-2.2G PICK -U P22
2-2.3A MANIFOLD and 2-2.3B I N - LINEW23
2-2.2H FOAMI23
2-2.3 Water Supply23
2-2.4 Control System24
Ystem24
Valve25
Pump25
Operation27
Foam System Operation27
Class a Foam - Using On-Board Foam Tank27
3-1.2 Classa Foam - Drafting28
3-1.3 Classb Foam - Drafting29
Flushing System30
3-2.1 General Flushing Information30
Manual Flush Mode30
3-2.3 Flushing after Drafting Classa Foam31
3-2.4 Flushing after Drafting Classb Foam31
Priming (Charging) System32
Filling Foam Tank33
3-4.1 On-Board Tank Fill33
3-4.2 Fill through Foam Tank Fill Dome36
Manual Mode37
Set-Up Mode37
Maintenance39
Maintenance Introduction39
Testing after System Maintenance39
Set-Up & Calibration40
Setup and Calibration40
4-2.1 Set-Up Mode40
4-2.1A CONFIGURATION PROCEDURE40
4-2.1B CHECK CURRENT SOFTWARE REVISION43
4-2.1C CHECKING HYDRAULIC SYSTEM PRESSURE43
Troubleshooting44
Periodic Operation57
General Maintenance Procedures57
Preventive Maintenance Checks and Service58
4-6.1 Introduction58
4-6.2 Explanation of Columns58
After Every Use Inspection58
Quarterly Inspection59
Annual Inspection59
4-10. Recommended Hydraulic Oil for Husky 3 Proportioning System60
4-10.1 Characteristics60
4-10.2 Recommendations60
4-10.3 Oil Change Information60
System Diagrams61

Pierce HUSKY 3 - List of Abbreviations

Table of Contents