Component Maintenance Manual
EFFECTIVITY: ALL
21-00-22
Page 9001
JULY 21, 2011
SPECIAL TOOLS, FIXTURES, AND EQUIPMENT
TASK 21-00-22-99F-803
10.0 SPECIAL TOOLS/EQUIPMENT
SUBTASK 21-00-22-99F-014
10.1 General:
10.1.1
This section describes the necessary tools and test equipment required to perform
maintenance, functional testing, troubleshooting, and repair procedures. Equivalent test
equipment may be substituted only if it meets the listed equipment specifications.
Regulated Shop Air 40 PSIG
Fin comb SK1250101-13
Miscellaneous hand tools and socket set
Shop vacuum with soft utility brush
Vacuum pump, air or electric 0-30 in.hg.
Gaseous dry Nitrogen, regulated source 0-500 PSIG
Reclaim/Recycle Cart (R12) (Robinair model # 342000) (preferred) or R12 refrigerant
charging manifold with gauges and hoses (low pressure gauge, 0-300 PSIG), (high pressure
gauge, 0-600 PSIG).
Thread sealant primer Loctite 7471
Thread sealant Loctite 569
RTV sealant 11602 Black
Hose adapter 1/2 in. male ACME to 1/4 in. female flare
Leak check fluid soap solution (Spec MS-SNOOP-GAL)
Refrigerant oil BVM100N
External or aircraft power source 200 amp.
Inspection mirror
Thermometer 0-150°F
Flashlight or service lamp
Refrigerant R12
Kent-More Flush Adapter J42939
Small “rare earth” magnet
Tape
To Next Page
Loading...
