3.4
MAINTENANCE
Brake Disc I I I I
Parking Brakes I I I I I
Brake System I
Brake Fluid R
FUEL MANAGEMENT
Pilot Air Screws I I I
Carburetor
(synchronize)
II I
Idle RPM I I I
Throttle Lever I I I I I
Oil Pump Lever
(synchronize)
II I
Throttle Cable L L L
Choke Cable L L L
Choke I I I
Vent Lines I I I I
Throttle Position
Sensor
II I
Fuel Lines I I I I I
Fuel Filter RR
Oil Filter RR
Oil Lines II I
Air Box I I I I I
Drain and Water Traps I I I
ELECTRICAL
Auxiliary Shut-Off Switch I I I I I I
Throttle Safety Switch I I I I I I
Ignition Switch I I I I I I
Taillight I I I I I I
Brakelight I I I I I I
Headlight I I I I I I
Tether Switch and Strap I I I I I I
CHASSIS
Ski Toe Alignment I I I
Suspension Mounting Bolts I I I I I I
Steering Fasteners I I I I C
Rear Suspension Fasteners I I I I I
Suspension Shock Oil I I I I
Cooling Fins and Shroud I I I I
Drive Shaft Bearing L L L I
Jackshaft Bearings L L L I
Skags (Wear Bars) I I I I I I
Ski Saddle/Spindle Bolts I I I I I I
Drive Chain Tension I I I I I
Hood Straps I I I I I I
Table 3-1: Maintenance Intervals
Item
Pre-Ride
Frequency Miles (km)
Pre-
Season
150 (240) 500 (240) 1000 (1600) 2000 (3200)
I:Inspect (clean, adjust, tighten, lubricate, replace if necessary) C:Clean R:Replace L:Lubricate
To Next Page
Loading...
Need help?
General
