Polaris BRUTUS Owner's Manual

130
TROUBLESHOOTING
Engine Doesn't Turn Over
Engine Turns Over, Fails to Start
Engine Runs Irregularly, Stalls or Misfires
Engine Stops or Loses Power
Possible Cause Solution
Low battery voltage Recharge the battery to 12.8 VDC
Loose battery connections Check all connections and tighten
Loose solenoid connections Check all connections and tighten
Loose electronic control box con-
nections
Inspect, clean, reinstall connectors
Possible Cause Solution
Out of fuel Refuel
Clogged fuel filter/water separator Replace
Clogged air filter Replace
Water is present in fuel Drain the fuel system and refuel,
replace fuel filter/water separator
Old or non-recommended fuel Replace with fresh recommended
fuel
Water or fuel in crankcase Immediately see your POLARIS
dealer
Low battery voltage Recharge the battery to 12.8 VDC
Mechanical failure See your dealer
Defective glow plug Inspect and replace
Defective stop solenoid Replace
Defective fuel pump Replace
Possible Cause Solution
Poor fuel quality or incorrect fuel Replace with recommended fuel
Low fuel level Refuel
Clogged fuel filter Replace
Clogged air filter Replace
Water present in fuel Replace with new fuel
Kinked or plugged fuel tank vent
line
Inspect and replace
Other mechanical failure See your dealer
Possible Cause Solution
Poor fuel quality or incorrect fuel Replace with recommended fuel
Clogged fuel filter Replace
Clogged air filter Replace
Water present in fuel Replace with new fuel
Kinked or plugged fuel tank vent
line
Inspect and replace
Other mechanical failure See your dealer
Out of fuel Refuel
Low battery voltage Recharge the battery to 12.8 VDC
Overheated engine Clean radiator screen and core,
clean engine exterior, operate at
lower load, see your dealer

Polaris BRUTUS Specifications

General

Brand	Polaris
Model	BRUTUS
Category	Utility Vehicle
Language	English