Polaris Sportsman 90 Service Manual (English)

Other manuals for Polaris Sportsman 90

Service Manual109 pages

Owner's Manual200 pages

Questions and Answers:

L
lenglishJul 26, 2025
What to do if oil does not pulse from the delivery line in my Polaris Sportsman 90 Offroad Vehicle?
- J
  Jeffrey FloresJul 26, 2025
  If the oil isn't pulsing from the delivery line every few seconds in your Polaris Offroad Vehicle, several factors could be at play. Start by checking the oil line for any blockages, leaks, or air pockets. Ensure the oil tank is filled with the correct type of oil. If the issue persists, test the oil pump and drive mechanism for any faults. Bleed air from the oil lines.
D
davisstephanieAug 1, 2025
Why does my Polaris Sportsman 90 Offroad Vehicle engine run irregularly, stall, or misfire?
- G
  griffinkatieAug 1, 2025
  If your Polaris Offroad Vehicle's engine runs irregularly, stalls, or misfires, several factors could be the cause. It could be due to fouled or defective spark plugs, which you should inspect, clean, or replace. Also, check for loose ignition connections and tighten them. Water in the fuel or incorrect fuel can also cause these issues, so replace the fuel. A clogged air filter should be inspected, cleaned, or replaced. Additionally, low battery voltage can be a culprit, requiring you to recharge the battery with a .5 amp charger. Finally, inspect and replace any kinked or plugged fuel vent lines. For worn spark plug wires, electronic throttle control malfunction, or other mechanical failures, consult your Polaris dealer.
C
Casey JonesAug 12, 2025
What causes a lean fuel mixture in my Polaris Offroad Vehicle?
- A
  Alexis CookAug 12, 2025
  A lean fuel mixture in your Polaris Offroad Vehicle can stem from a few issues. You might have low or contaminated fuel, in which case you should add or change the fuel and clean the fuel system. Using low octane fuel can also cause this, so replace it with the recommended fuel. A clogged fuel filter is another possibility, so replace the filter.
J
Jason TerrellAug 18, 2025
How to fix a rich fuel mixture in my Polaris Sportsman 90?
- T
  Terry StewartAug 18, 2025
  A rich fuel mixture in your Polaris Offroad Vehicle could be due to overuse of the choke, which requires you to inspect, clean and/or replace spark plugs. It could also be caused by using very high octane fuel; if that's the case, replace it with lower octane fuel.