57
Cosmetic Care & Maintenance
TYPICAL MAINTENANCE SCHEDULE-VOLVO IPS DIESEL ENGINE
The IPS propulsion package is designed to provide
many years of reliability and satisfaction. To keep the
unit running at peak performance a service maintenance
schedule is recommended. Only basic information is conveyed
here. Refer to the Volvo operation manual for detailed information
or contact a Volvo authorized service center.
AVOID PERSONAL INJURY
BEFORE PERFORMING ANY MAINTENANCE
WORK READ AND UNDERSTAND THE
OWNER’S MANUAL. IT CONTAINS THE
RECOMMENDED PROCEDURES.
MAINTENANCE POINTS MARKED WITH A
* MUST BE PERFORMED BY AN
AUTHORIZED VOLVO PENTA DEALER.
BEFORE EACH OUTING OR DAILY:
♦ Engine & Sump- General inspection
♦ Engine Oil- Check Level
♦ Coolant- Check Level
♦ Leaks- Check After Starting Engines
♦ Drive Unit Oil- Check Level
EVERY 14 DAYS
♦ Drive Belts- Wear Check
♦ Seawater Filter- Clean
♦ Battery- Check Electrolyte Level
(1) Oil change intervals vary, depending on oil grade and
sulfur content of fuel.
EVERY 100-200 HOURS OR YEARLY
♦ Engine Oil- Change (1)
♦ Engine OIl Filter- Change (2)
EVERY 200 HOURS OR YEARLY
♦ Crankcase Ventilation Filter- Change
♦ Air Filter- Change
♦ Drive Belts- Check Tension
♦ Compressor- Check Oil Level
♦ Seawater Pump- Check Impeller
♦ Sacrifi cial Anodes- Check Air Cooler, Heat Exchanger
♦ Fuel fi lters- Change
♦ Paint- Touch-Up As Needed
* Exhaust & Cooling Hoses
* Hose Clamps- Tighten
* EVC System- Check With Diagnostic Equipment
EVERY 400 HOURS OR YEARLY
♦ Drive Unit- Oil & Fllter- Change
♦ Drive Unit- Corrosion Protection- Check Anodes
EVERY SECOND YEAR
♦ Coolant- Change
EVERY 400 HOURS OR YEARLY
♦ Drive Unit- Oil & Fllter- Change
♦ Drive Unit- Wear Check Propeller & Steering
EVERY 600 HOURS OR ONCE EVERY 5 YEARS
♦ Turbocharger- Inspect & Clean
♦ Drive Unit- Wear Check Propeller & Steering
(2) Always change the oil fi lter with each oil change.
To Next Page
Loading...
