RPS CONDOR 150 - User Manual

OWNER’S MANUAL
CONDOR 150
No one under the age of 16 should operate this 150CC motorcycle without adult supervision.
Parents should consider child’s age, size, maturity and ability before allowing to ride.
Always wear a helmet; It could save your Life!
This manual should be considered as a permanent part of the vehicle and should remain with
the vehicle when resold or otherwise transferred to a new user or operator. The manual
contains important safety information and instructions which should be read carefully before
operating the vehicle.
Please obtain, review, and follow the municipal, provincial and government acts and
regulations pertaining to owning and operating an the vehicle.

Summary

Introduction and General Safety

Warranty Information

Engine and Frame Warranty Terms

Covers warranty period for engine and frame, void conditions.

Warranty Void Conditions

Lists circumstances that invalidate the warranty.

Customer Support and Requirements

Provides contact info and sales receipt requirement.

Understanding Safety Symbols

Safe Operation Procedures

Pre-Ride Checklist

Essential checks before operating the motorcycle.

Essential Safety Gear

Warning Label Locations

Technical Specifications

Parts Identification

Dashboard Indicator Guide

Speed, Odometer, and Trip Meter

Explains indicators for distance and speed.

Warning and Signal Indicators

Details indicators for lights and gear status.

Instrument Setup Function

Describes how to set the vehicle instrument display.

Fuel System Management

Fuel Filling Procedure

Instructions for safely filling the fuel tank.

Fuel Valve Operation Modes

Explains ON, OFF, and RESERVE fuel valve settings.

Starting and Stopping the Engine

Cold Engine Starting Procedure

Steps to start a cold engine with choke.

Engine Stopping Procedure

Steps for safely shutting down the engine.

Engine Break-In Guidelines

Handlebar Controls Overview

Ignition and Emergency Stop Switches

Explains the function of key switches on the handlebar.

Lubrication and Oil Maintenance

Checking Engine Oil Level

Procedure for verifying engine oil level.

Recommended Lubricating Oil

Guide to selecting the correct engine oil grade.

Changing Engine Oil and Filter

Steps for replacing engine oil and cleaning the filter screen.

Ignition and Valve System Checks

Spark Plug Inspection and Gap Adjustment

How to check and adjust the spark plug.

Valve Clearance Inspection

Procedure for checking valve clearance.

Air Filter Maintenance

Throttle and Carburetor Adjustment

Throttle Cable Free Play Adjustment

How to adjust throttle cable slack.

Carburetor Idle Speed Adjustment

Steps to set the engine's idle speed.

Brake System Inspection

Front Hydraulic Disk Brake Inspection

How to inspect the front brake system.

Rear Hydraulic Disk Brake Inspection

How to inspect the rear brake system.

Clutch Adjustment Procedures

Clutch Lever Play Adjustment

Adjusting the free play in the clutch lever.

Clutch Tension Adjustment

Adjusting the clutch cable tension.

Drive Chain Maintenance

Drive Chain Adjustment

Steps for adjusting drive chain tension.

Drive Chain Greasing

How to lubricate the drive chain.

Troubleshooting Engine Issues

Fuel Supplying Check

Verifying fuel delivery to the carburetor.

Ignition System and Stalling Issues

Ignition System Spark Test

Procedure to test the ignition spark.

Troubleshooting Engine Stalls

Common causes and checks for engine stalling.

Vehicle Washing Guidelines

Long-Term Storage Instructions

Service Resumption and Torque Specs

Resumption of Service After Storage

Steps to prepare the vehicle after storage.

Table of Torque Specifications

Specific torque values for fasteners.

General Resumption of Service

Procedures for bringing the vehicle back to service.

Scheduled Maintenance

Serial Number Identification

Wiring Diagram

Emission Control System Warranty

Your Warranty Rights and Obligations

Explains owner's rights and manufacturer's duties.

Manufacturers Warranty Coverage

Details what the warranty covers and for how long.

Owners Warranty Responsibilities

Outlines owner's duties for maintaining warranty.

Emission Control Warranty Details

Warranty Coverage and Limitations

Specifies covered items and exclusions.

Limited Liability Statement

Defines the extent of manufacturer's liability.

Warranty Policy and Claims

Legal Rights and Warranty Modification

Discusses legal rights and dealer modification restrictions.

Warranty Repair Eligibility and Claims

Process for evaluating and submitting warranty claims.

Parts Delivery and Labor Reimbursement

How parts and labor costs are handled for repairs.

Additional Warranty Information

Covers OEM parts, receipts, complaints, and defect reporting.

RPS CONDOR 150 Specifications

General

Fuel System	Carburetor
Transmission	5-Speed Manual
Starting System	Electric and kick start
Front Suspension	Telescopic fork
Front Brake	Hydraulic Disc