20
TROUBLESHOOTING
This troubleshooting guide is provided to help you to find the cause of some common complaints.
COMPLAINT: Engine is hard to start or does not start at all. Something is probably wrong with the fuel
system or ignition system.
CAUTION
Failing to troubleshoot a problem correctly would damage your motorcycle.
Improper repairs or adjustments may damage the vehicle. Such damage may not be covered under
warranty. If you are not sure about the proper action, consult your dealer. About the problem.
FUEL SUPPLYING CHECK
1. Make sure there is adequate fuel in the fuel tank.
2. Check that the engine stop switch is in the “RUN “ position.
3. Check that the fuel valve is in the “ON” position.
4. Make sure there is enough fuel reaching the carburetor from the fuel tank.
WARING
Draining fuel from the carburetor could be hazardous.
Fuel could catch fire if you do not handle it properly.
When draining the carburetor, be sure to shut the engine off. Do not smoke, and never drain or refuel
or you may create a fire hazard. Dispose of drained fuel properly.
a. Loosen the drain screw which is located under the carburetor. Drain the fuel from the carburetor into a
container.
b. Tighten the drain screw.
c. Run the engine for a few seconds. Shut off engine.
d. Loosen the drain screw and check that the carburetor is filled back up with fuel.
e. If fuel is reaching the carburetor, the ignition system should be checked next.
To Next Page
Loading...
Need help?
General
