6-4
Engine runs irregularly, stalls or misfires
Possible Cause Solution
Fouled or defective spark plugs Inspect, clean and/or replace spark plugs
Worn or defective spark plug wires Contact your Segway dealer
Incorrect spark plug gap or heat
range
Set gap to specs or replace plugs
Loose ignition connections Check all connections and tighten
Water present in fuel Replace with new fuel
Low battery voltage Recharge battery to 12.5 VDC
Engine runs irregularly, stalls or misfires
Possible Cause Solution
Kinked or plugged fuel vent line Inspect and replace
Incorrect fuel Replace with recommended fuel
Clogged air filter Inspect and clean or replace
Reverse speed limiter malfunction Contact your Segway dealer
Electronic throttle control malfunction Contact your Segway dealer
Other mechanical failure Contact your Segway dealer
Possible Lean or Rich Fuel Mixture
Cause
Solution
Low or contaminated fuel
Add or change fuel, clean the fuel
system
Low octane fuel Replace with recommended fuel
Clogged fuel filter Replace filter
Incorrect jetting Contact your Segway dealer
Overuse of choke
Inspect, clean and/or replace spark
plugs
High fuel octane Replace with lower octane fuel
To Next Page
Loading...
