Snorkel S2255RT - Table of Contents

S2255RT S2755RT - 15286-1
Table of Contents
Electrical Danger .........................Inside Front Cover
Proposition 65 Warning ...............Inside Front Cover
Danger Symbols ..........................Inside Front Cover
Lanyard Anchor Points ................Inside Front Cover
Safety Rules ................................Inside Front Cover
Chapter 1 – Introduction
Aerial Platform Features ..........................................1
Options ....................................................................1
Operator’s Manual ...................................................1
Safety Alerts ............................................................1
Operation .................................................................1
Maintenance ............................................................2
Manual of Responsibilities – ANSI...........................2
MEWP Safe Use – AS/NZS .....................................2
AS/NZS 1418.10 Commissioning ............................2
Additional Information ..............................................2
Chapter 2 – Specifi cations
Component Identifi cation .........................................3
General Specifi cations – S2255RT .........................4
General Specifi cations – S2755RT .........................5
General Specifi cations – S2255BE .........................6
General Specifi cations – S2755BE .........................7
Chapter 3 – Safety
Electrocution Hazards .............................................9
Minimum Safe Approach Distance – ANSI ..............9
Minimum Safe Approach Distance – AS/NZS..........9
Platform Capacity ..................................................10
Manual Force.........................................................10
Wind Speeds .........................................................10
Prestart Inspection.................................................10
Work Place Inspection and Practices ....................10
Operation ................................................................11
Tip-Over and Falling Hazards .................................11
Electrical System ...................................................12
Hydraulic System...................................................12
Placards and Decals..............................................12
General Safety Rules ............................................12
Engine and Fuel Handling precautions .................13
Chapter 4 – Safety Devices
Safety Device Information .....................................15
Emergency Stop Switches.....................................15
Upper Controls ...................................................15
Lower Controls ...................................................15
Alarms ...................................................................15
Lowering .............................................................15
Drive (reverse) ...................................................16
Drive (forward) ...................................................16
Load Sensing System............................................16
Level Sensor..........................................................16
Dual Tilit Limits ......................................................16
Primary Fall Restraint System ...............................16
Safety Prop ............................................................17
Swinging Gate .......................................................17
Interlock Switch .....................................................17
Bubble Level ..........................................................17
Operator Horn........................................................17
Stabilisers ..............................................................17
Rought Terrain Scissor Interlock Test ....................18
Enable Switch (Lower Controls Only) ....................18
RCD/ELCB Outlet (Option) ....................................18
Electrical Power Outlet (Option) ............................18
Flashing Light ........................................................18
Fall Restraint Lanyard Anchor Points ....................18
Chapter 5 – Gauges and Displays
Diagnostic Center Display .....................................21
Platform Overload/Lift Enable Lights .....................21
Warning Light ........................................................21
Hydraulic Oil Tank ..................................................21
Chapter 6 – Controls
Battery Disconnect ................................................23
Lower Controls ......................................................23
Emergency Stop Button .....................................23
Control Selector .................................................23
Ground Operation Switch ...................................23
Platform Raise/Lower Switch .............................23
Lift Indicator Light ...............................................24
Platform Overload Indicator Light .......................24
Choke Switch/Glow Plug Switch ........................24
Start Switch ........................................................24
Fuel/Electric Switch ............................................24
Upper Controls ......................................................24
Emergency Stop Button .....................................24
Drive/Lift Selector Switch ...................................25
Joystick ..............................................................25
Interlock Switch ..................................................25
Steer Switch .......................................................25
Drive Range Switch ............................................25
Horn Button ........................................................25
Stabiliser Manual Switches ................................25
Auto Level/Stow Switch ......................................25
Lift Indicator Light ...............................................25
Drive Indicator Light ...........................................25
Warning Light .....................................................25
Platform Overload Indicator Light .......................25
Choke Switch/Glow Plug Switch ........................25
Start Switch ........................................................25
Fuel/Electric Switch ............................................25
Chapter 7 – Prestart Inspection
Operator’s Manual .................................................27
Safety Prop ............................................................27
Cables and Wiring Harness ...................................28
Hydraulic System...................................................28
Fluid Level ..........................................................28
Hoses, Tubes, and Fittings .................................28
Free-Wheeling Valve ..........................................29
Diagnostic Center Display .....................................29
Tires and Wheels ...................................................29
Lower Control Station ............................................29
Operating Controls .............................................29
Emergency Stop .................................................29
Lowering Alarm ..................................................30
Stabiliser Interlock Test ......................................30
Stabiliser Locked Out When Platform Elevated .30
Elevation Locked Out When Axles Not Stowed .30
Elevation Locked Out When Tilted Test ..............30
Emergency Lowering System ................................30
Structures ..............................................................31