Snorkel S3970RT - Table of Contents

Table of Contents
Electrical Hazard
Electrical Hazard Warning ..................i
Introduction
Standard S3970RT / S3370RT / S2770RT
Version III ..............................ii
Options ................................ii
Operation Manual ........................ii
Photographs ............................ii
Safety Alerts ............................ii
Operation ..............................iii
Maintenance............................iii
Responsibilities of parties .................iii
Product Warranty ........................iv
Additional information ....................iv
1. Safety
Safe Operation ........................1-1
Electrocution Hazards ...................1-1
Pre-start Inspection .....................1-1
Work Place Inspection and Practices .......1-1
Operation.............................1-2
Tipover and Falling Hazards ..............1-2
General Safety Precautions ..............1-3
Hydraulic System Precautions ............1-3
Fire / Explosion Prevention ...............1-3
Engine and Fuel Handling Precautions......1-3
Batteries .............................1-4
Safety Decals and Placards ..............1-4
Safety Placards and Decals Location .......1-4
2. Safety Devices
Safety Device Information ................2-1
Emergency Stop Switches ...............2-1
At platform control box .................2-1
At ground control box ..................2-1
Alarms ...............................2-1
Lowering ............................2-1
High temperature .....................2-2
Low oil pressure ......................2-2
Alternator not charging .................2-2
Drive (reverse) .......................2-2
Drive (for ward) .......................2-2
Load sensing system....................2-2
Level sensor .........................2-2
Primary Fall Restraint System.............2-2
Safety Prop ...........................2-3
Safety Control .........................2-3
Bubble Level ..........................2-3
Operator Horn ........................2-3
Stabilisers (Option) .....................2-4
Rough Terrain Scissor Interlock Tests ......2-4
Enable switch ........................2-4
RCD/ELCB AC Outlet (option) ............2-4
Flashing Light .........................2-5
Fall Restraint Lanyard Anchor Points
(option) ..............................2-5
3. Specifications
Specifications .........................3-1
General Specifications, Standard Machine
S3970RT .............................3-1
General Specifications, Standard Machine
S3370RT .............................3-2
General Specifications, Standard Machine
S2770RT .............................3-3
Engine Data...........................3-4
DF752 (Option) .......................3-4
D902 ...............................3-4
Machine Component Identification .........3-5
4. Gauges
EzCal LCD Display .....................4-1
Water................................4-1
Alternator.............................4-1
Oil Pressure...........................4-1
Hours................................4-1
Work time ...........................4-1
Total time ...........................4-1
Engine Oil ............................4-1
Hydraulic Oil Level .....................4-1
Bubble Level ........................4-2
5. Automatic Shut-offs and Circuit Breakers
Automatic Shut-offs ....................5-1
Level sensor .........................5-1
Engine temperature ...................5-1
Engine oil pressure ....................5-1
Platform height vs. drive speed...........5-1
Dynamic brakes ......................5-1
Alternator not charging .................5-1
Load sensing system ..................5-1
Stabilisers ..........................5-2
Fuses ...............................5-2
RCD / ELCB outlet (option)..............5-2
6. Controls
Controls ..............................6-1
Hydraulic Compartment..................6-1
Ground Control Box.....................6-1
Platform Control Box ....................6-2
7. Daily Inspection and Maintenance
Daily Inspection and Maintenance Table ....7-1
S3970RT, S3370RT & S2770RT – 13865-1 page - vi