Stels 650 GUEPARD - Driving and Operation; Engine Start and Running-in Procedures; Driving Basics and Techniques; Maintenance and Technical Information

4
650/800/850 GUEPARD
CONTENTS
OPERATION
Engine start................. .........................................42
Transmission gear lever control................ .......43
Engine running-in...................................... .......44
Parking............................................................45
Parking on slopes...........................................45
Transportation of loads...................................46
DRIVING THE VEHICLE category T3b
Explore your vehicle category T3b...............................48
Training course............................................................48
Gear..............................................................................50
Preliminary checks before operation.......................51
Speed limiting device.................................................51
Transportation of loads and extra equipment.........52
Accessories..................................................................52
Exhaust system...........................................................53
Driving...........................................................................53
Use caution while driving............................................54
Motion start..................................................................56
Turning....................................................................57
Going uphill..................................................................58
Going downhill........................................................61
Going across the slope................................................62
Crossing the fords................................................63
Cross-country movement............................................65
Skidding and drifting.................................................65
Reverse movement................................................66
4WD/LOCK driving mode characteristics...............67
PERIODIC MAINTENANCE
AND MINOR DEFECT REPAIR
Maintenance procedure.............................................68
Lubrication recommendations...........................75
Panel removal and installation.................................76
Footrest removal and installation..................................77
Trunk removal and installation.................................77
Spark plug check..........................................78
Engine oil level check......................................79
Engine oil and filter replacement...........................80
Front axle housing oil replacement.......................81
Rear axle housing oil replacement..................82
Transmission gear oil replacement.........................83
Cooling agent level check.......................................84
Brake lever free travel....................................85
Brake pedal height check...............................85
Brake fluid level check............................................86
Brake fluid replacement............................................87
manufacture website : stelsoffroad.com
CONTENTS 650/800/850 GUEPARD
5
RELEVANT INFORMATION !
Provided the product is operated properly its service lifetime is 5 years.
Pre-Sale Preparation.........................................100
Scrappage....................................................102
Warranty service provisions...............................103
Warranty certificate............................................105
Servicing...........................................................106
Electric circuit diagram.......................................108
Control unit electric diagram...............................112
Small wiring harness electric diagram...............114
Lighting engineering...........................................115
Dachboard electric diagram..............................116
EPS electric diagram..........................................117
Cut - out and relay unit electric diagram.............118
Trailer plait, fog lamp and fan harness ..............119
Notes..................................................................121
Brake lining check.....................................................87
Throttle lever free travel.........................................88
Wheel removal and installation................................89
Headlamp check and adjustment.............................90
Headlamp bulb replacement....................................91
Valve expansion gap adjustment..............................91
Dust covers..............................................................91
Filter cartridge replacement......................................92
Fuse replacement.....................................................93
Accumulator charge and storage................................94
Vehicle category T3b
washing................................95
Short-term storage...............................................96
Long-term storage and preservation....................96
The vehicle category T3b transportation............98
Packing, transportation........................................99
manufacture website : stelsoffroad.com