Sym CRUiSYM - Routine Inspection and Checks; Routine Inspection Checklist; Engine Oil Inspection and Change

10. Inspection and maintenance before riding
15
(Please refer to the components location diagram for the following components.)
ROUTINE INSPECTION
Check Items
Check Key Points
Engine Oil
Is there enough engine oil?
Fuel
Is it enough? Is it Octane 92 or higher
Brake
Front
Braking condition?
(Brake lever free play: 10~20mm)
Rear
Braking condition?
(Brake lever free play: 10~20mm)
tires
Front
Is tire pressure normal?
(Standard: 2.0 kgf/cm
2
)
Rear
Is tire pressure normal?
(Standard: 2.5 kgf/cm
2
)
Steering Handle
Does the handle rotate abnormally or is difficult to turn?
Speedometer, lights,
and rearview mirror
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Tightness of Main
Components
Are screws, nuts loose?
Abnormal Points
Do the previous troubles still exist?
CAUTION:
 If any problem founded during routine inspection, correct the problem before using the scooter again,
have your scooter checked and repaired by the“SYM” dealer or authorized service personnel” if
necessary.
ENGINE OIL INSPECTION AND CHANGE
INSPECTION:
1. Use the main parking stand to support the scooter on a level ground, remove the dipstick after engine
stopped for 3~5 minutes. Wipe oil off the dipstick first, and then insert it into the guide tube again (Do
not run the engine.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase…etc for leakage.)
OIL CHANGE:
 Change engine oil after the first 1,000km, and change the engine
oil every 5,000km thereafter. Clean oil filter after the first 1,000km,
and then clean the oil filter every 10,000km.
 In order to maintain the engine’s maximum performance, check
whether the engine oil is enough at every 1,000km. Add oil to
upper limit if the engine oil has been found to be inadequate.
 Engine Oil : Use API SJ, SAE 10W-40 grade or better engine oil.
Otherwise, damage will not be covered by warranty.
※ Recommended Oil: Genuine SYM〝SYMOIL〞ENGINE OIL.
 Oil Capacity : 1.4 Liter (1.2 liters for routine change),
Upper
limit
Lower
limit