Sym Maxsym TL TL 500 - Spark Plug Inspection; Air Cleaner; V-Belt Case Air Cleaner Inspection

44
Spark Plug Inspection
Have the spark plug checked by an authorized SYM dealer. If the electrodes are contaminated with heavy
deposits or the insulator is damaged, replace with a new one. Measure the spark plug gap ○A with a wire
type feeler gauge. The gap should be within 0.8 ~ 0.9 mm. If adjustment is needed, bend the side electrode
○B carefully.
Recommended spark plug
NGK CPR7EA-9
Spark plug gap
0.8 ~ 0.9 mm
Tightening torque
1.2 kgf-m
WARNING:
 Beware of the engine heat when inspecting the spark plug.
Engine Air Cleaner / V-belt Case Air Cleaner Inspection
A dirty engine air cleaner element can reduce the engine performance and increase fuel consumption.
The engine air cleaner is element is located behind the front left cover ○A .
Inspect the engine air cleaner by following the below instructions.
 Turn ignition switch off and set the scooter upright.
 Open the left storage compartment cover and remove the 2 screws ○A .
 Remove the 2 screws ○A on the rear side of the front right cover.
○A
○B
○A
○A