Synesso MVP Hydra User Manual


32
MAINTENANCE
MAINTENANCESCHEDULE
Daily
1.Backflusheachbrewgroupwithoutdetergentthroughouttheday.
2.Backflushwithanespressoindustryapproveddetergentduringthefinalcleaningofthenight(oraera
busyperiod),andthenagainwithoutdetergenttorinse.
3.Wipedowntheenremachinewithasocloth.
4.Removeportafilters,basketsandsprings,driptrayandgratesandcleanthoroughly.Theseitemsareall
dishwashersafe.
5.Slowlypourapitcherofhotwaterdownthedraintocleargroundsdebrisandpreventblockage.
Weekly
1.Soakportafiltersandtheremovedfilterbasketsinanapprovedespressoindustrydetergentandwater
soluonovernight.Rinsethoroughlybeforereassemblingandusingyourportafilters.
2.Carefullyremovescreensfromeachbrewgroupusingashorthandledscrewdrive randsoakovernightin
asimilarsoluonastheportafilters.
3.Rinsescreensthoroughlybeforeinstallingandusing.Makesureyouinstallthescreensbeforebrewing
anyshotsofespresso.Failuretodosomayplugthedrainlineswithcoffeegrounds.
Monthly
1.Checkyourwaterfiltraonsystemandmakesurethecartridgesandfiltersarechangedasneeded.Inar‐
easofhighmineralcontent,hardwater,highparculatecountorinverybusylocaons,thefiltraonsys‐
temswillneedtobecheckedmoreoen.
Quarterly
1.Changeportafiltergasketsandcloselyinspectdiffuserscreensandfilterbaskets,Iftheseitemsareshow‐
ingwear,pleasereplacethemas
soonaspossible.Changetheseitemsiftheyshowdamageoroveruse.
2.Brieflyinspectthemachineforleaksorpotenalissues.ContactSynesso™oryourlocaldistributororser‐
viceagenttoorderpartsand/orrequestservice.

Synesso™recommendsthatyoucontactyourdistributororserviceagentforperiodicmaintenance.Thefre‐
quencyofmaintenancevisitswilldependonavarietyoffactorsincludinghowmuchusethemachinere‐
ceives,butatleastonepreventavemaintenancevisitayearisrequired.Duringthisyearlyservice,allbody
panelsmustberemovedandallconneconsbothelectricaland
hydraulicmustbeinspected.Smallprob‐
lemscanbecomelargeifnotcaughtearly.

Synesso MVP Hydra Specifications

General

Pump Type	Rotary
PID Temperature Control	Yes
Pre-infusion	Yes
Volumetric Dosing	Yes
Boiler Material	Stainless Steel
Pressure Profiling	Yes
Material	Stainless Steel
Water Reservoir	Direct plumb only