Operation & Maintenance Manual
CD-135 / CD-155
OM-02-02
Chapter:
Issue:
Issue date:
Page:
Content:
02-OM-06-02
4
30.07.2014
10
74
Revision no.:
Revision date:
7
20.07.2016
6.3 Maintenance Actions based on Time
6.3.1 Every month
• Protect engine against corrosion. Start-up the engine for at
least 20 minutes
(refer to Chapter 4, Section 4.2, Page 2 of this Manual)
6.3.2 Every 12 months
• Replace excitation battery of the alternator
(refer to Annex 16, Page 67 of this Chapter)
• Exchange engine oil and oil filter
(refer to Annex 5, Page 16 of this Chapter);
A sample of the oil and the used oil filter should be labeled,
stored in a clean container and made available to Technify
Motors GmbH on request for the complete engine life time.
The sample will be required for a later long-run analysis.
The label must show the aircraft serial number, registration
number, engine serial number, operation time and date.
Quantity of oil to be taken for sample: 100ml
• Exchange gearbox oil and gearbox oil filter
(refer to Annex 13, Page 52 of this Chapter);
A sample of the oil and the used gearbox oil filter should be
labeled, stored in a clean container and made available to
Technify Motors GmbH on request for the complete engine
life time. The sample will be required for a later long-run
analysis. The label must show the aircraft serial number,
registration number, engine serial number, operation time
and date.
Quantity of oil to be taken for sample: 100ml
WARNING: Under extreme conditions such as low usage combined with
operation in a salt-water environment, or in a very dusty and
sandy environment, shorter maintenance and inspection
intervals are recommended for your own safety.
Note: Chapter 1, Section 1.10, Page 5 of this Manual must be
observed.
To Next Page
Loading...
Need help?
General
