THOR Jayco NORTH POINT 2021 - General Slideout Troubleshooting Checklist

To Next Page

To Previous Page





Main Page

Table of Contents3
Section 1: Warranty & Service11
- Factory Tours11
- Options and Equipment11
- Dealer Responsibility11
- Customer Relations11
- To Contact Us13
About this Manual13
Warranty Packet14
Safety Alerts14
Reporting Safety Defects15
Customer Responsibility16
Change of Address/Ownership16
Suggestions for Obtaining Service16
Obtaining Service for Separately Warranted Items17
Obtaining Service at Our Customer Service Facility17
Parts and Accessories17
Section 2: Occupant Safety25
Secondary Means of Escape (Exit Window)25
Fire Safety26
Fire Extinguisher26
Smoke Alarm27
Combination Carbon Monoxide /Propane Alarm28
Formaldehyde32
Extended or Full Time Usage32
Cold Weather Usage32
Condensation33
Section 3: Pre-Travel Information35
Tow Vehicle35
Vehicle Labels35
- Weight Terms35
- Weight and Capacity Labels35
Loading Your Recreation Vehicle37
Cargo Carrying Accessory Receiver (if so Equipped)37
Rear Bumper38
Fifth Wheel Pin Box (Customer Supplied)38
- Fifth Wheel Pin Box39
- Fifth Wheel Pin Box Height39
- Fifth Wheel Hitching Procedure39
Wire Harness/Connector Plug39
Weighing Your Tow Vehicle and RV40
Section 4: Vehicle Operation43
Towing43
- RV Brake System44
- Electric Brakes44
- Brake Controller (Customer Supplied)45
- Travel Trailer Breakaway Switch45
- Hydraulic Brakes (if so Equipped)45
- Disc Brakes (if so Equipped)45
Towing Behind Your RV46
Stowable Entrance Door Step (if so Equipped)46
Entrance Door47
Rear Backup Camera Prep48
Campsite Hook-Up48
LCI 3.0 Leveling System (if so Equipped)49
- Auto Leveling Control Touch Pad49
- Auto Leveling Touch Pad50
- Onecontrol Touch Panel51
- Onecontrol App (for Your Phone or Tablet)51
  - Onecontrol Touch Panel52
  - Linc Remote52
- Linc Remote Control52
- Troubleshooting52
Dexter EZ Flex Equalizer (if so Equipped)53
Stabilizer Jacks53
- Manual Stabilizer Jacks (if so Equipped)53
- Electric Stabilizer Jacks (if so Equipped)53
Emergency Stopping54
Emergency Towing55
Wheel Lugs55
- Wheel Lug Nut Diagrams56
- Wheel Lug Nut Torque Values56
Tires57
Changing a Tire59
Spare Tire Carrier (if so Equipped)60
- Hoist Mount60
- Bumper Mount61
Setting up Your Recreation Vehicle62
- Travel Trailer Set up62
- Fifth Wheel Set up62
Cargo Ramp Door62
- Cargo Ramp Transition Label63
- Manual Ramp Door64
- Automated Ramp Door (if so Equipped)64
Cargo Ramp Door Capacity65
Loading the Cargo Area65
- Weight Distribution66
- Air Vents66
Awnings (if so Equipped)67
- Awning Care67
Power Awnings (if so Equipped)68
- Carefree® Longitude Awnings (if so Equipped)68
- Electric Patio Awning with Remote Control68
- In Motion Detector (if so Equipped)68
- Carefree® Travel'r Awnings (if so Equipped)70
- Section 5: Slideout Systems73
Electric Slide Room(S) (if so Equipped)73
- Slideout Overlap-Outside74
- General Slideout Troubleshooting Checklist74
- Flush Floor Slideout74
- Schwintek In-Wall Slideout System76
- Norco Slideout System79
- Power Gear Slideout System80
- Power Gear Slim Rack Slideout System82
- Power Gear Ram Slideout System87
- Section 6: Electrical System89
The Electrical System89
In Case of an Electrical Fire89
Command Center90
- Command Center Panel90
- Command Center Panel W/Switch Modules90
GFCI Receptacle91
Command Control System (if so Equipped)91
Bmpro Rvmaster System (if so Equipped)92
Testing the Campsite Power Connection99
Inverter (if so Equipped)101
Power Converter102
- Converter with Charge Wizard (if so Equipped)103
12-Volt DC System104
- 12-Volt Fuse Panel104
- Replacing a Fuse104
- 12-Volt DC Outlet104
Auxiliary Battery (Customer Supplied)105
- Dry Camping105
  - Battery Disconnect Switches106
- Replacement and Maintenance106
- Battery Isolator for Your Tow Vehicle (Customer Supplied)106
- Battery Disconnect Switch (if so Equipped)106
Load Center107
120-Volt Circuit Breakers107
- Typical Load Center Panel107
- Load Center Panel W/120 Volt Main Breaker107
Approximate Electrical Load Ratings108
120-Volt 50 AMP AC Electric System (if so Equipped)109
Generator110
- 50 Amp Power Cord110
- Calculating 50 Amp Electrical Load (if so Equipped)110
Solar Prep (if so Equipped)112
LED Decorative Light Strips (if so Equipped)112
Replacing Light Bulbs112
- Solar Plug112
- Section 7: Fuel & Propane System113
Exhaust Gas Fumes113
Propane Gas System113
- Propane Gas Container114
- Servicing or Filling115
- LP Gas Container Overfill116
- Maintenance116
- Propane Cylinder Recertification116
- Hoses, Pipes, Tubes and Fittings116
- Propane Regulator117
Propane Use and Safety118
- Using the Propane System118
  - Propane System Label118
- Cooking with Propane Gas119
- Calculating Propane Gas Usage119
- Traveling with Propane120
Installing Propane Cylinder(S)120
- Single Cylinder120
- Main Supply Hose121
- Double Cylinder121
- Section 8: Plumbing System123
Plumbing System123
- Plumbing System Maintenance123
Monitor Panel123
- Command Center124
Fresh Water System125
- Water Pressure Regulator (Customer Supplied)125
Water Purification System (if so Equipped)126
- Water Pump Strainer126
- Filter Housing126
Draining the Fresh Water System127
- Exterior Fresh Water Drain127
Uni-Dock Utility Center (if so Equipped)128
- Low Point Drains128
- Sanitizing the Plumbing System132
- Winterizing the Plumbing System (with Utility Center)135
- Tank Style (Storage) Water Heater136
- Tankless (on Demand) Water Heater136
- Winterizing the Black Tank Flush138
- Draining the Spray Port (if so Equipped)138
- Winterizing the Spray Port with Antifreeze138
- Winterize with Antifreeze Method139
- Winterizing the Macerator System (if so Equipped)140
Water Heater141
- Gas/Electric DSI Tank (Storage) Water Heater System (if so Equipped)141
  - Anode Rod Replacement Chart142
- Water Heater Bypass (if so Equipped)142
TRUMA® Tankless Water Heater (if so Equipped)146
- Opening the Exterior Water Heater Panel146
- Filling the Water Heater147
- Turn Water Heater on147
- Aqua Go Comfort Plus Models148
- Draining the Aqua Go Water Heater149
- Winterization150
Faucets153
Bathroom Tub / Shower153
Outside Shower (if so Equipped)153
Black/Grey Water System and Tanks154
Black and Grey Tank Drains156
- Black/Grey Tank Drain and Valves156
Macerator Pump System (if so Equipped)157
Black Tank Flush (if so Equipped)158
Tank Heaters (if so Equipped)159
Toilet (if so Equipped)160
Spray Port (if so Equipped)161
Section 9: Heating & Cooling163
Air Conditioner163
- Roof Mount (if so Equipped)163
- Wall Mount (if so Equipped)163
- Heat Pump Operation (if so Equipped)163
Power Roof Vent (if so Equipped)163
- Attic Fan Control163
Ceiling Fan (if so Equipped)164
Furnace164
Fireplace (if so Equipped)165
Section 10: Appliances167
Microwave167
Cooking Safety167
- In Case of a Grease Fire167
Cooktops, Range and Oven (if so Equipped)168
- Cooking with Propane (if so Equipped)168
Gas BBQ Grill (if so Equipped)170
Attaching the "Quick Coupler" Connection171
- Quick Connect Coupler171
- Gas Grill and Mounting171
- Bracket on Support Rail171
Range Hood (if so Equipped)172
Refrigerator172
Washer/Dryer Prep (if so Equipped)174
Vacuum Systems (if so Equipped)174
Water Heater - See Plumbing Section175
Outside Kitchen (if so Equipped)175
- Quick Coupler Connection176
- Exterior Refrigerator176
- LP Gas Grill (if so Equipped)176
- Section 11: Electronics179
Winegard Air 360 Plus System (if so Equipped)179
- Opening the Router Box180
Exterior Sliding / Pivoting TV183
Section 12: Interior185
Cleaning the Interior185
- Décor Glass (if so Equipped)185
- Furniture Upholstery185
Sofa and Dinette187
- Hide-A-Bed Sofa or Sofa Sleeper187
- Jack Knife Sofa187
- Trifold Sofa187
- Cube Sofa188
- Booth Dinette (if so Equipped)188
- Free-Standing Table and Chairs (if so Equipped)188
Pantry or Hutch (if so Equipped)189
Countertops189
- Laminate Countertops (if so Equipped)189
- Solid Surface Countertops (if so Equipped)189
Flooring190
- Carpet190
- Vinyl Flooring190
Bed Storage190
- Prop Rod (if so Equipped)190
- Gas Struts (if so Equipped)191
Loft Sleeping Area (if so Equipped)191
Bunk Beds (if so Equipped)193
Bunk Bed Ladder (if so Equipped)193
Safe (if so Equipped)194
Section 13: Exterior195
Cleaning the Exterior195
Frame197
E-Z Lube or Super-Lube Axle (if so Equipped)197
Exterior Roof and Sidewall Vents197
Windows198
Exterior Ladder (if so Equipped)198
Sealants199
Fifth Wheels - Sealant Diagram200
Section 14: Travel/Camping/Storage Checklists201
Travel Checklist201
RV Storage202
Section 15: Additional Information205
Featured Components Quick Reference Chart205
Vehicle Maintenance Record207
- Ownership Notification208

THOR Jayco NORTH POINT 2021 - General Slideout Troubleshooting Checklist

Table of Contents

Related product manuals