Tracker LS2 2020 - Scheduled Maintenance Chart

B
SCHEDULED MAINTENANCE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
141
Repair and Service Manual
699322
SCHEDULED MAINTENANCE CHART
Perform all services at the maintenance interval reached
first.
S –Indicates operations that need to be performed on
vehicles subjected to severe use.
E –Indicates emission-related services (Failure to do this
maintenance will not void the emissions warranty but may
affect emissions).
D –Indicates services that must be performed by an
authorized dealer.
Item
Interval
(perform at interval
that comes first)
Remarks Page
Hours Calendar
Steering Pre-ride Check for smooth and free operation.
Front suspension Pre-ride Inspect. Check for leaks and loose or missing hardware.
Rear suspension Pre-ride Inspect. Check for leaks and loose or missing hardware.
Tires Pre-ride Check condition and pressure. 11, 43
Wheel lug nuts Pre-ride Check for loose or missing. 21
Accelerator Pre-ride Check for smooth operation. 84
Brake system Pre-ride Check for proper operation. 25
Frame hardware Pre-ride Check for loose or missing.
Fuel and engine oil
level
Pre-ride Check for correct level. 143
Air filter Pre-ride Inspect. Clean or replace as needed. 75
Headlights and tail-
lights
Pre-ride Check operation. Replace bulbs as needed.
Reverse warning
alarm
Pre-ride Check operation.
Switches Pre-ride Check operation.
Fluid leakages Pre-ride Inspect entire vehicle for leaks
CVT belt Pre-ride Check condition.
Engine oil and filter Initial Service Replace oil and filter at first 50 hours of operation.
Starter/generator
belt
Initial Service Check between first 15 and 20 hours.
Wheels Weekly Check condition of rims, missing or loose lug nuts.
S
E
Air filter Weekly Inspect. Replace as needed.
S Cooling fins Weekly Check for build-up of dirt inside blower housing and fins; clean
as necessary.
S Engine oil Weekly Check level; add as necessary.
Starter/generator
belt
Weekly Check condition.
S Brake shoes 10 Monthly Inspect. Replace as needed.
Parking brake 20 Monthly Conduct brake performance test; adjust as necessary
Wiring 20 Monthly Inspect for loose connections, broken or missing insulation.
Direction selector 20 Monthly Inspect attachment and mechanism; adjust as necessary.
Steering 20 Monthly Check for excess play, loose or missing hardware.
S Tie rods 20 Monthly Check for excess play, bent rods, loose or missing hardware.