Tracker LS2 2020 - Recommended Lubricants and Fluids; Replacement of Maintenance Items

B
SCHEDULED MAINTENANCE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
143
Repair and Service Manual
699322
RECOMMENDED LUBRICANTS AND
FLUIDS
Check and lubricate all components at the intervals
shown in the SCHEDULED MAINTENANCE CHART
beginning on page 141.
REPLACEMENT OF MAINTENANCE
ITEMS
These items or their equivalents can be purchased
through an authorized dealer, directly from E-Z-GO or any
other qualified source.
Cylinder head and
piston
500 5 years Check valve seats for carbon buildup; clean if necessary.
Rear axle 500 5 years Replace fluid.
Item
Interval
(perform at interval
that comes first)
Remarks Page
Hours Calendar
Item Capacity Lubricants/Fluids Notes
Engine oil 1.3 qt. (1.25
L)
10W-30 Light duty use engines
10W-30 Heavy duty use in air temperatures below
40º F (4º C)
10W-40 Heavy duty use in air temperatures above
40º F (4º C) after 100 hour break-in period
Fuel 5.96 Gallon
(22.6 L)
Unleaded; 87 octane min
10% ethanol content max.
Rear axle oil 51 oz. (1.5
L)
MOBIL 424
Grease fittings Universal joint grease or equivalent Do not exceed 3 pumps of grease in
each fitting.
Item Part Number
Oil Filter 607454
Air Filter 28463G01
Spark Plug (NGK BPR2ES) 607462
Starter/Generator Belt 630587
Clutch Belt 618630
15A Fuse 636455G13
10A Fuse 636455G12
Fuel Pump Relay 663593
Headlight Bulb 74004G02
Turn Signal Bulb 676687
Taillight Bulb 604311