Home
Trane
Air Conditioner
Foundation GCC180-300
Trane Foundation GCC180-300 User Manual
4
of 1
of 1 rating
52 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
RT
-SVX51L-EN
15
Figure
10.
Cooling
with
optional
electric
heat
—
manual
damper
NOTE:
VERIFY WEIGHT
, CONNECTION, AND ALL DIMENSIONS WITH INST
ALLER DOCUMENTS BEFORE INST
ALLATION.
BACK VIEW OF UNIT
LEFT VIEW OF UNIT
F
AN
MANUAL DAMPER
HOOD
123 1/8”
18 1/4”
26 7/8”
24 7/8”
12 13/16”
86 15/16”
Dimensional
Data
14
16
Table of Contents
Table of Contents
4
Model Number Description
6
General Information
7
Unit Inspection
7
Exterior Inspection
7
Inspection for Concealed Damage
7
Unit Storage
7
Unit Description
7
Economizer Control Actuator Electromechanical Control
8
JADE Economizer Control - Low Leak Economizer (LLE) Only
8
Functions
8
Sensors
8
Initiation of Operating Modes - JADE
9
Controller
9
Dimensional Data
10
Weights
16
Rigging
17
Installation
18
Unit Foundation
18
Horizontal Units
18
Ductwork
18
General Unit Requirements
18
Factory Installed Economizer
19
Main Electrical Power
19
Requirements
19
External Vent Hood Installation
19
TCO1 Instructions
20
Instructions
20
Condensate Drain Configuration
23
Filter Installation
23
Field Installed MERV13 Filters
23
Field Installed Power Wiring
23
Main Unit Power
24
Standard Wiring
24
Optional TBUE Wiring (through the Base Electrical Option)
24
Control Power Transformer
24
Controls Using 24 Vac
24
Requirements of Gas Heat
25
Gas Heat Data
26
Voltage Imbalance
27
Motors)
27
Compressor Crankcase Heaters
28
Checklist
28
Factory-Mounted Unit Options
28
Unit Disconnect (FIYUDC)
28
Through the Base Gas Utility Option
29
Field Installed Connections
29
Pre Start
31
Verifying Proper Air Flow (Units with Belt Drive Indoor Fan)
31
Electromechanical Controls - Test
31
Procedure
31
Start up
32
Electromechanical Controls - Sequence of
32
Operation
32
Cooling Without an Economizer
32
Evaporator Fan Operation (for Gas Units) - Standard Economizer
32
Evaporator Fan Operation
32
Only Units) - Standard
32
Economizer
32
Economizer Set-Up - Standard
32
Cooling with an Economizer - Standard
32
Heating Operation (for Gas Units) - Standard Economizer
33
Ignition Module Low, Medium and High
33
Heat
33
Drain Pan Condensate Overflow Switch
33
(Optional)
33
Low Ambient Operation (Optional)
33
Two-Speed Indoor Fan Control
33
Cooling Operation
33
Economizer Minimum Position Handling for 2-Speed Fan
34
Phase Monitor
34
Low Pressure Cutout
34
High Pressure Cutout and Temperature
34
Discharge Limit
34
Locking Safety Device with Compressor Anti Short Cycle
34
Timer
34
Coil Frost Protection
34
Heating Operation
34
Emergency Stop
34
JADE Controls - Low Leak Economizer
35
Sequence of Operation
35
Economizer Set-Up
36
Drain Pan Condensate Overflow Switch
36
(Optional)
36
Low Ambient Operation (Optional)
36
Two-Speed Indoor Fan Control
36
Phase Monitor
37
Low Pressure Cutout
37
High Pressure Cutout and Temperature
37
Discharge Limit
37
Coil Frost Protection
37
Initiation of Operating Modes
37
Standard Economizer Start-Up
37
LLE Controls Test Procedure
37
Compressor Start-Up
38
Heating Start-Up
38
Final System Set up
38
Maintenance
39
Fan Belt Adjustment-Belt Drive Units
39
Monthly Maintenance
40
Filters
40
Condensate Overflow Switch
40
Cooling Season
40
Heating Season
41
Coil Cleaning
41
Troubleshooting
44
Standard Troubleshooting
44
Ignition Module
44
Failures
44
Low Leak Economizer - (LLE)
44
Resetting Cooling and Heating
45
Lockouts
45
Method 1
45
Method 2
45
Condensate Overflow Switch
45
Unit Economizer Control (ECA)
45
Error Code
46
Wiring Diagrams
47
Warranty
48
For Commercial Unitary Equipment Rated
48
Tons and under and Related Accessories
48
Basic Warranty
48
Exclusions and Limitations
48
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Trane Foundation GCC180-300 and is the answer not in the manual?
Ask a question
Trane Foundation GCC180-300 Specifications
General
Brand
Trane
Model
Foundation GCC180-300
Category
Air Conditioner
Language
English
Related product manuals
Trane Foundation GCC 090-150
40 pages
Trane Foundation GBC180
52 pages
Trane Foundation GBC090
40 pages
Trane Foundation GBC210
52 pages
Trane Foundation EBC240
48 pages
Trane Foundation EBC300
48 pages
Trane Foundation EBC180
48 pages
Trane Foundation EAC180AD
28 pages
Trane Force Flo Cabinet Heater
160 pages
Trane FC
80 pages
Trane UniTrane FCD 721
64 pages
Trane UniTrane FCD 408
64 pages
Need help?
General
To Next Page