Trane IntelliPak RA 20

To Next Page

To Previous Page

134

RT-SVX063E-EN

Symbio 800 Replacement

See Programming Guide (RT-SVP011*-EN) Symbio UI

section for instructions to replace and upgrade the

Symbio 800 controller.

Final Process

Record the unit data in the blanks provided.

SSeerrvviiccee aanndd MMaaiinntteennaannccee

Main Page

Table of Contents4
Model Number Description8
General Information10
- Unit Nameplate10
- Compressor Nameplate10
- Gas Heat Nameplate10
- Unit Description10
Pre-Installation11
- Unit Inspection11
- Storage11
- Unit Clearances11
- Factory Warranty Information11
Dimensional Data13
- Roof Curb20
- Electrical Entry Details24
- Access Clearances25
Installation27
- Roof Curb and Ductwork27
- Unit Rigging and Placement27
- General Installation Requirements29
- Electrical Data31
  - Electrical Service Sizing31
  - Main Unit Power Wiring36
- Supply Fans38
  - Remove Shipping Tie down38
  - Installation39
- Refrigeration System40
  - Condensate Drain Connections40
  - Compressor Crankcase Heaters41
- Gas Heat Units41
- Electric Heat Units48
- Economizer and Relief Air Damper48
- Adjustment48
Startup the Unit56
- Electrical Phasing56
- Verifying Proper Fan Operation56
- Direct-Drive Supply Fan Speed58
- Adjustment58
- System Airflow Measurements58
- Gas Furnace Startup59
- Final Unit Checkout61
- Trane Startup Checklist62
  - Critical Control Parameters and Dry Bulb Changeover Map63
  - Sequence of Operation65
Stop/Off/Auto65
Power-Up Start Delay65
Normal Unit Starting65
Rapid Restart Operation65
Occupancy65
- Occupancy Status Definitions65
- Timed Override66
- Service Pin Message Request66
Sensors66
Heat Cool Mode Status66
Operating Modes67
- Unit67
- Circuit68
Unit Sub-Modes68
- Morning Warm up68
- Pre Cool69
- Night Purge69
- Daytime Warm up69
- Idle69
Supply Fan Control70
- Supply Fan Speed Control70
- Supply Fan Proving Operation and Method70
- Single Fan Operation70
Supply Fan VFD Bypass Control70
- Entering VFD Bypass Control70
- Mode70
- Supply Fan Proving with VFD71
- Bypass71
- Operation During Manual Override and vom (Emergency Override)71
- Modes71
Minimum Ventilation Control71
- Outdoor Air Flow Control (Traq)71
- Outdoor Air Flow71
- Control71
- (DCV)71
- Compensation72
- Control72
- Space Static Pressure Control with Statitrac TM73
- Space Static Pressure Control Without Statitrac TM73
Discharge Air Temperature Control73
Multi Zone-VAV and Constant Volume - Discharge Temperature Units73
- Supply Air Tempering73
- Changeover Input73
- VAV Box Relay Output73
- Discharge Air Reset74
- Duct Static Pressure Control74
- Duct Static Pressure High Limit74
Space Temperature Control74
- Auto Changeover74
Space Temperature Control Units75
- Single Zone VAV75
- Temperature Control76
Compressor Staging and Timers76
- General Compressor Staging76
- Evaporator Coil Surface Utilization77
- (Two Circuit Units Only)77
- Compressor Lockout and Inhibit77
- Alternate Staging Sequence77
- Compressor Staging with Variable77
- Speed Compressors77
- Balanced Compressor Staging78
Compressor Protections78
- Low Ambient Lockout78
- Low Compressor Suction Pressure78
- Protection78
- Temperature and Pressure Sensor79
- Failures79
- Oil Management Protection79
- Limit79
- Compressor Discharge Saturated79
- Temperature Limit79
- Compressor Discharge Saturated Temperature Speed Limit79
- High Suction Saturated Temperature79
- Inhibit79
- Compressor Involute Pressure79
- Superheat High Limit Detection80
- Variable Speed Compressor Modulating Current Limit80
- Compressor Low Suction Saturated Temperature Speed Limit80
- Coil Frost Protection80
- Head Pressure Control80
Hot Gas Bypass80
- Hot Gas Bypass Control81
EXV Control81
Valve)81
- Configuration82
- Functional Description82
- Operation82
- Operating Modes82
Economizing82
Outdoor Air Damper Fault Detection and Diagnostics (FDD)83
Dehumidification Control83
Occupied83
- Discharge Air Control Units83
- Units84
Dehumidification Control84
Unoccupied84
Heat Types84
- Gas Heat84
- Electric Heat - Staged86
- Electric Heat - Modulating86
- Electric Heat Protection86
- External Heat86
Unoccupied Cooling86
Unoccupied Heating86
External Control87
- External Supply Fan Control87
- External Relief Fan Control87
- External Outdoor Air Damper88
- Control88
Overrides88
- Local Stop88
- Emergency Stop89
- External Stop89
- Manual Control89
- Heat/Cool Capacity Lockouts and Limits91
- Condensate Overflow92
- Filter Status92
Controls93
- Constant Volume System Controls93
  - Constant Volume Zone Panel93
  - (Baysens108*)93
- Compressor Motor Winding93
- Thermostats93
Performance Data97
- Supply Fan Curves97
- Relief Fan Curves100
- Component Static Pressure Drops102
- Refrigeration105
Service and Maintenance106
- Monthly Maintenance109
- Scroll Compressor Replacement111
- VFD Programming Parameters128
- Eflex™ Compressor VFD Programming Parameters133
Microchannel Condenser Coil Repair and Replacement133
- Fall Restraint133
Symbio 800 Replacement134
- Final Process134
Wiring Diagrams136
Warranty and Liability Clause138
- Accessories138

Table of Contents

Related product manuals