Trane IntelliPak RA 20 User Manual

RT-SVX063E-EN
3
WWAARRNNIINNGG
FFoollllooww EEHHSS PPoolliicciieess!!
FFaaiilluurree ttoo ffoollllooww iinnssttrruuccttiioonnss bbeellooww ccoouulldd rreessuulltt iinn
ddeeaatthh oorr sseerriioouuss iinnjjuurryy..
•• AAllll TTrraannee ppeerrssoonnnneell mmuusstt ffoollllooww tthhee
ccoommppaannyy’’ss EEnnvviirroonnmmeennttaall,, HHeeaalltthh aanndd SSaaffeettyy
((EEHHSS)) ppoolliicciieess wwhheenn ppeerrffoorrmmiinngg wwoorrkk ssuucchh aass
hhoott wwoorrkk,, eelleeccttrriiccaall,, ffaallll pprrootteeccttiioonn,, lloocckkoouutt//
ttaaggoouutt,, rreeffrriiggeerraanntt hhaannddlliinngg,, eettcc.. WWhheerree llooccaall
rreegguullaattiioonnss aarree mmoorree ssttrriinnggeenntt tthhaann tthheessee
ppoolliicciieess,, tthhoossee rreegguullaattiioonnss ssuuppeerrsseeddee tthheessee
ppoolliicciieess..
•• NNoonn--TTrraannee ppeerrssoonnnneell sshhoouulldd aallwwaayyss ffoollllooww
llooccaall rreegguullaattiioonnss..
Overview of Manual
NNoottee:: This document is customer property and must be
retained by the unit owner for use by
maintenance personnel.
These units are equipped with electronic Unit Control
Modules (UCM). Refer to the “Start-Up” and “Test
Mode” procedures within this Installation, Operation,
and Maintenance manual and the latest edition of the
appropriate programming manual for Constant Volume
(CV), Variable Air Volume (VAV), or Single Zone
Variable Air Volume (SZVAV) applications before
attempting to operate or service this equipment.
IImmppoorrttaanntt:: The procedures discussed in this manual
should only be performed by qualified and
experienced HVAC technicians.
This booklet describes proper installation, start-up,
operation, and maintenance procedures for
applications. By carefully reviewing the information
within this manual and following the instructions, the
risk of improper operation and/or component damage
will be minimized.
NNoottee:: One copy of the appropriate service literature
ships inside the control panel of each unit.
It is important that periodic maintenance be performed
to help assure trouble-free operation. Should
equipment failure occur, contact a qualified service
organization with qualified, experienced HVAC
technicians to properly diagnose and repair this
equipment.
IImmppoorrttaanntt:: DO NOT release refrigerant to the
atmosphere!
If adding or removing refrigerant is required, the
service technician must comply with all federal, state,
and local laws.
Copyright
This document and the information in it are the
property of Trane, and may not be used or reproduced
in whole or in part without written permission. Trane
reserves the right to revise this publication at any time,
and to make changes to its content without obligation
to notify any person of such revision or change.
Trademarks
All trademarks referenced in this document are the
trademarks of their respective owners.
Factory Training
Factory training is available through Trane University™
to help you learn more about the operation and
maintenance of your equipment. To learn about
available training opportunities contact Trane
University™.
Online: www.trane.com/traneuniversity
Phone: 855-803-3563
Email: traneuniversity@trane.com
Revision History
• Updated Sequence of Operations chapter.
• Updated Roof Curb Dimension Data (inches) table
in Dimensional Data chapter.
• Added Compressor Staging tables to Compressor
Motor Winding Thermostats section.
IInnttrroodduuccttiioonn

Trane IntelliPak RA 20 Specifications

General

Brand	Trane
Model	IntelliPak RA 20
Category	Air Conditioner
Language	English