Trane SINTESIS ADVANTAGE CGAF Series - Page 16

16
CG-SVX039C-GB
Table 3 – General data CGAF 080-190 Extra Efficiency
CGAF CGAF CGAF CGAF CGAF CGAF CGAF CGAF CGAF CGAF
80 90 100 110 130 140 150 165 180 190
XE XE XE XE XE XE XE XE XE XE
Net Cooling Capacity (1) (kW) 297.5 337.4 376.4 426.6 477.2 522.5 561.5 608.0 660.3 708.8
Net Total Power input (1) (kW) 87.1 98.5 110.8 126.4 143.0 155.3 169.4 186.0 197.4 213.9
Unit electrical data (2) (3) (4)
Short Circuit Unit Capacity (kA) 15 15 15 15 15 15 15 15 15 15
Power Cable Cross Section
(max)
mm²
1*240 1*240 1*240 1*240 1*240 2*300 2*300 2*300 2*300 2*300
Disconnect switch size (A) 315 400 400 500 500 630 630 630 800 800
Maximum Power input (kW) 125.30 148.12 167.29 181.49 195.70 227.82 246.99 261.19 279.04 293.24
Unit rated amps (A) 205.58 239.84 268.3 296.08 323.86 367.24 395.7 423.48 457.06 484.84
Unit start up amps
(w/o soft starter -
Digit 54=A) (4)
(A) 419.01 473.04 501.5 634.39 662.17 600.44 628.9 761.79 795.37 823.15
Unit start up amps
(with soft starter -
Digit 54=B) (4)
(A) 315.01 355.44 383.9 469.19 496.97 482.84 511.3 596.59 630.17 657.95
Displacement power factor
(dpf)
(dpf) 88% 89% 90% 88% 87% 90% 90% 89% 88% 87%
Compressor
Compressor Number per
Circuit
# 2 2 2 2 2 3 3 3 3 3
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Model Circuit 1 / Circuit 2 kW
25+25/
25+25
25+30/
25+30
30+30/
30+30
30+40/
30+40
40+40/
40+40
25+30
+30/25
+30+30
30+30
+30/30
+30+30
30+30
+40/30
+30+40
30+40
+40/30
+40+40
40+40
+40/40
+40+40
Max Comp Power input
Circuit 1 / Circuit 2
kW
28.4+28.4/
28.4+28.4
28.4+38.2/
28.4+38.2
38.2+38.2/
38.2+38.2
38.2+45.2/
38.2+45.2
45.2+45.2/
45.2+45.2
28.4+38.2
+38.2/28.4
+38.2+38.2
38.2+38.2
+38.2/38.2
+38.2+38.2
38.2+38.2
+45.2/38.2
+38.2+45.2
38.2+45.2
+45.2/38.2
+45.2+45.2
45.2+45.2
+45.2/45.2
+45.2+45.2
Rated Amps Circuit 1 /
Circuit 2
(A)
47+47/
47+47
47+61/
47+61
61+61/
61+61
61+75/
61+75
75+75/
75+75
47+61
+61/47
+61+61
61+61
+61/61
+61+61
61+61
+75/61
+61+75
61+75
+75/61
+75+75
75+75
+75/75
+75+75
Locked Rotor Amps Circuit
1 / Circuit 2 (direct start -
Digit 54=A)
(A)
260+260/
260+260
260+294/
260+294
294+294/
294+294
294+413/
294+413
413+413/
413+413
260+294
+294/260
+294+294
294+294
+294/294
+294+294
294+294
+413/294
+294+413
294+413
+413/294
+413+413
413+413
+413/413
+413+413
Locked Rotor Amps Circuit
1 / Circuit 2 (Soft starter -
Digit 54=B)
(A)
156+156/
156+156
156+176/
156+176
176+176/
176+176
176+248/
176+248
248+248./
248+248
156+176
+176/156
+176+176
176+176
+176/176
+176+176
176+176
+248/176
+176+248
176+248.
+248/176
+248+248
248+248
+248/248
+248+248
Motor RPM (rpm) 2900 2900 2900 2900 2900 2900 2900 2900 2900 2900
Oil sump heater Circuit 1 /
Circuit 2
(W)
90+90/
90+90
90+90/
90+90
90+90/
90+90
90+90/
90+90
90+90/
90+90
90+90
+90/90
+90+90
90+90
+90/90
+90+90
90+90
+90/90
+90+90
90+90
+90/90
+90+90
90+90
+90/90
+90+90
Evaporator
Quantity # 1 1 1 1 1 1 1 1 1
1
Type Stainless steel Copper Brazed plate Heat exchanger
Evaporator model
DFX650
x138
DFX650
x138
DFX650
x166
DFX650
x194
DFX650
x222
DFX650
x250
DFX650
x278
DFX650
x278
DFX650
x278
DFX650
x294
Evaporator Water Content
volume
(l) 40.4 40.4 48.6 56.7 64.9 73.1 81.3 81.3 81.3 86
Nominal water connection
size (Grooved coupling) -
Without HYM
(in) -
(mm)
4" -114.3 4" -114.3 4" -114.3 4" -114.3 4" -114.3 5" -139.7 5" -139.7 5" -139.7 5" -139.7 5" -139.7
Nominal water connection
size (Grooved coupling) -
With HYM
(in) -
(mm)
4" - 114.3 4" - 114.3 4" - 114.3 4" - 114.3 4" - 114.3 5" -139.7 5" -139.7 5" -139.7 5" -139.7 5" -139.7
Hydraulic Module Components
Single pump - Standard head
pressure option
Max available Head
Pressure
(kPa) 155 136 119 102 87 141 137 115 159 146
Motor Power (kW) 5.5 5.5 5.5 7.5 7.5 7.5 7.5 11 11 11
Rated Amps (A) 11 11 11 14.4 14.4 14.4 14.4 20.8 20.8 20.8
Single pump - High head
pressure option
Max available Head
Pressure
(kPa) 280 266 254 241 232 252 257 245 229 218
Motor Power (kW) 11 11 11 11 11 15 15 15 15 15
Rated Amps (A) 20.8 20.8 20.8 20.8 20.8 28 28 28 28 28
General Data