Trane Symbio 800 - Table of Contents

4 CDUB-SVN002B-EN
Table of Contents
General Information . . . . . . . . . . . . . . . . . . . . . 5
Summary of UC800 Display Upgrade . . . . 5
Unit Model Number . . . . . . . . . . . . . . . . . . . . 5
Model Number Descriptions . . . . . . . . . . . . . . 6
Getting Started . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Nameplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Symbio 800 AdaptiView Display Upgrade Kit
Contents
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Running the IPC Bus . . . . . . . . . . . . . . . . . 7
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Installation of UC800 Control Upgrade . . . 9
Check the Configuration and Set-Points in the
AdaptView Display . . . . . . . . . . . . . . . . . . . 9
Save the AdaptView Configuration and Set-
Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Upgrading Display Firmware . . . . . . . . . . . 10
Update the Display Original X-CODE to Sym-
bio Display X-CODE . . . . . . . . . . . . . . . . . 13
Shut Down Power . . . . . . . . . . . . . . . . . . 13
Remove the Existing UC800 controller and In-
stall New Symbio 800 Controller . . . . . . 13
Remove the Existing Display and Install New
Display (When Required) . . . . . . . . . . . . . 14
Solid State Oil Heater Relay Installation . 14
Mounting Location . . . . . . . . . . . . . . . . . . 14
Installation . . . . . . . . . . . . . . . . . . . . . . . . 15
Installation of Options . . . . . . . . . . . . . . . . . 16
LON Option . . . . . . . . . . . . . . . . . . . . . . . . 16
Communication Option . . . . . . . . . . . . . . 16
Communication Device Mounting . . . . . 17
Water Flow Measurement Options . . . . . 18
Energy Meter Option Installation . . . . . . 20
Expansion Module Option . . . . . . . . . . . . 21
Starter Up . . . . . . . . . . . . . . . . . . . . . . . . . 22
Restoring System Power . . . . . . . . . . . . . 22
Programming . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Programming the Symbio 800 AdaptiView
23
Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Wiring Diagrams . . . . . . . . . . . . . . . . . . . . . . . 27