Wacker Neuson AS 50e - General Safety Instructions - Fuel, Lubricants and Coolants; Maintenance; General Safety Instructions - Rechargeable Battery (Accessories)

4 Security
12 100_0201_si_0002.fm
 Pay maximum attention near drops or slopes. Risk of crashing!
 In trench applications and pits, pay very close attention to the side walls to ensure they are stable and
do not collapse from the vibration. Danger of collapse!
 Never leave the machine running unattended. Risk of injury!
 Delimit spacious workspace and restrict access to unauthorized individuals. Risk of injury!
 Machine operators must ensure that people in the working area keep a minimum distance of 2 meters
from the running machine.
 Only use Wacker Neuson rechargeable batteries. These batteries are vibration proof and are
therefore suitable for the high vibration exposure.
4.10 General safety instructions – fuel, lubricants and coolants
The following notes must be observed:
 Always wear safety glasses and protective gloves when handling fuel, lubricants, and coolants. Seek
medical attention, for example if you get oil or grease in your eyes.
 Avoid direct skin contact with fuel, lubricants and coolants. Immediately rinse skin with soap and
water.
 Do not eat or drink while working with fuel, lubricants and coolants
 Contaminated oil from dirt or water can lead to premature wear or failure of the machine
If fuel, lubricants and coolants escape from the machine, do not operate the machine any longer and
have it repaired immediately by the Wacker Neuson contact partner.
4.11 Maintenance
The following notes must be observed:
 This machine may not be maintained, repaired, adjusted or cleaned while switched on. The
rechargeable battery must be removed.
 Adhere to maintenance intervals.
 Observe the maintenance schedule. Non-listed work must be taken over by the service department
of the Wacker Neuson contact partner.
 Immediately replace worn or damaged machine parts. Only use spare parts from Wacker Neuson.
 Keep the machine clean.
 Missing, damaged, or illegible safety warning labels should be replaced immediately. Safety stickers
contain important information for the protection of the operator.
Maintenance jobs must be performed in a clean and dry vicinity (e.g. workshop).
4.12 General safety instructions - Rechargeable battery (accessories)
The following notes must be observed:
 To charge the Wacker Neuson rechargeable batteries, only use the battery charger approved by
Wacker Neuson.
 Wacker Neuson rechargeable batteries may only be used in the machine specified for this purpose
by Wacker Neuson.
 Rechargeable batteries may not be dismantled, opened or deformed.
 The rechargeable batteries may not be exposed to heat or fire. Storage in direct sunlight is to be
avoided.
 Rechargeable batteries may not be shorted out.
 Rechargeable batteries may not be stored in a box or draw as this can pose hazards where a mutual
short-out can occur or a short-out can occur due to other conductive materials.
 Use the rechargeable battery for its intended purpose and protect it from damage.
 Rechargeable batteries may not be exposed to any mechanical impacts.
 If a rechargeable battery is leaking, the fluid must not come into contact with your skin or eyes. If
contact has been made, wash the affected area with plenty of water and seek immediate medical
attention.
 The polarity identification of plus and minus on the rechargeable battery and the machine must
always be observed. Proper use must be ensured.
 Rechargeable batteries that are not intended for use together with the machine may not be used.
 Keep rechargeable batteries away from children.
 Seek immediate medical attention if rechargeable battery components are accidentally swallowed.
 Keep rechargeable batteries clean and dry. Do not allow them to come into contact with water.
 If the connections of rechargeable batteries become dirty, clean these with a dry and clean cloth.