Wetrok Scrubo 43 E - 4 Proper Use; 4.1 Improper Use Warnings; 4.2 Hazardous Materials Handling

24
25
2 GENERAL
Emergencies:
• Immediatelyexerciserstaidorseekassistance.
• Removemainsplug(E-Version)orkey-operatedmainswitch(B-Version).
• Afteranyincidents,donotreactivatethemachineuntilmanufacturerhasinspectedthemachine.
3 TECHNICAL IMPROVEMENTS
Themachineisdesignedinlinewithcurrenttechnologyandinconformitywithrecognisedsafetyregulations.Ithasundergoneinspection
ofelectricalsystemsandconformswithEuropeansafetystandards(CE).Ithasvariouscircuitbreakersthatactasprotectionsystems.
Hazardscanneverthelessarise,chieythroughimproperuseorinfringementsofsafetyregulationsandinstructionssetoutintheoperating
manual.Wereservetherightatanytimetomaketechnicalmodicationstothemachineinadditiontoconsumablesandaccessories.For
thisreason,discrepanciesmayexistbetweencertaindetailsaboutthemachineandwhatissetdownintheoperatingmanual.
4 PROPER USE
• Thismachineisdesignedforindustrialoorcleaningofhardoorcoveringsininteriorareasinadherencethisoperatingmanual.
• Onlyuseconsumablesandaccessoriesrecommendedbythemanufacturer.Onlyoriginalbrushesandpadplatesmaybeused.
• Safetyregulationsrelatingtooperationandmaintenancearesetoutintherelevantchapters,andadherencetotheseregulationsismandatory.
4.1 Improper use
•
Itisforbiddentooperatethemachineifwhenitistechnicallyunsoundorifthefollowingsafetyregulationsandhazardsinformationaredisregarded.
• Protectiveguardsmustnotbedismantlednorbypassed.
• Conversionsandmodicationstotheproductarenotpermittedwithoutthemanufacturer’sauthorisation.
• Wheredamageoccursresultingfromdisregardingthisoperatingmanualaswellasimpropertreatmentorusingthemachineotherthan
foritsintendedpurpose,thenclaimsundertheguaranteewillbevoid.Noliabilitywillbeacceptedforconsequentialdamage.
• Themachinemustnotbeusedintheopenairinwetconditionsorstoredundersuchconditions.
The machine must not be used for the following purposes because of the associated hazards:
• Asatowingvehicle,meansoftransport,ortoy.
• Forcleaningtextileoorcoverings(theexceptiontothisissingle-discmachinesdesignedforthispurposewiththeproperaccessories).
4.2 Types of dust and liquids that are potentially harmful to health
The machine must not be used for the following purposes because of the associated hazards:
• Forabsorptionorremovalofdustthatisharmfultohealthandcombustiblematerials.
• Forvacuumcleaningofammable,toxic,corrosive,irritating,radioactivematerialsormaterialsharmfultohealth.
• Forcleaningofoorsnearammableorexplosivesubstances.
4.3 Limiting values
• Themaximum2%rise/inclinelimitfortransportationandduringoperationmustnotbeoverstepped.Afteruse,themachinemustbe
securedagainstrollingaway.
• Airhumidityduringoperationmustbebetween30-95%.
• Vibrationlevelisbelow2.5m/s2
• Noiseemissionisbelow74dBA.
5 Commissioning
5.1 Before commissioning
Before commissioning / Initial commissioning
• Delivery,orinstructionsonsafetyregulations,handlingandmaintenance,inadditiontoinitialcommissioning,arenormallyundertaken
byanapprovedexpert.Ifthisisnotthecase,theoperatingcompanyisresponsibleforinstructingtheoperator.
• Itemsofjewellery,suchasringsandchains,mustberemoved.
• Withmains-operatedmodels,checkthemainscableregularlyfordamage,suchassplittingorageing;ifdamageisdetected,havethe
mainscablereplacedbyanexpertbeforefurtheruse.
• Replacethemainscableonlyaccordingtothetype/dimensionsspeciedintheinstructionsforuse(seeunderPoint6).
• Allpanelsandcoversmustbeintheircorrectpositionsbeforecommissioning.
5.2 During operation
• Whenmachineisstopped,thebrushsetmustbeswitchedoffimmediatelytopreventanydamagetooorcoverings.
• Attachbrushes,padsandotheraccessoriesonlyasdirectedbytheillustratedoperatingmanual.
Machine and parts in motion
• Travellingmotionandareainvicinityofrotatingbrushes/padsposeariskofinjury.
• Donotgraspbrush/padsorwheelswithyourhandsorplaceyourfeetinthiszone.
• Doallowmachinetocomeintocontactwithitemsofclothing,jewelleryorhair.
DE
FR
IT
ES
EN
FI
NL
SV
DA
PL
PT
TR
AR
Deutsch
Français
Italiano
Español
English
Suomi
Nederlands
Svenska
Dansk
Polski
Português
Türkçe