Wetrok Scrubo 43 E - 5 Commissioning; 5.1 Pre-Commissioning Steps; Moving Parts Safety; 6 Safety Information for Mains-Operated Cleaning Machines

26
27
6 SAFETY INFORMATION FOR MAINS-OPERATED CLEANING MACHINES
Voltage/Current - attention: potentially fatal
• Themachinemustnotbeusediftheconditionofthemainscableisunsound.
• Beforerepairworkondefectiveelectricalinstallations,themachinemustnotbeconnectedtothemains.
• Themainscablemustnotbesqueezedordamaged.
• Thereisariskofthemainscablebecomingentangledwhilstbrushes/padsarerotating.
• Thevoltageindicatedonthetypeplatemustcorrespondwiththevoltageinthebuilding(+/-5%).
 Contactwithcurrentorvoltageinvolvestheriskofelectricshock,whichcouldresultininjuriessuchasburnsorevenfatality.Damaged
mainscablesmustneverbetouchedandmustbechangedwithoutdelay.
• Defectivemainscablesmayonlybereplacedbyaconductorcross-sectionof3x1.5mm2accordingtoDIN58281/VDE0281.
• ConnectionsofmainscablesmustbeprotectedagainstspraywateraccordingtoIP54protection.
• ThemachinemustbeprotectedbyaTypeHpowerswitchwitharatedcurrentof15Aora15Afuse.
7 SAFETY INFORMATION FOR BATTERY-OPERATED CLEANING MACHINES
• Batteriescontaincorrosivesulphuricacid.Nottobetakeninternally!Avoidcontactwithskinandeyeswithoutfail.
• Duringwet-cellcharging,thebatterycompartmentmustbeopenwithoutfail,otherwisethereisadangerofexplosionbyelectrolytic
gas.Adangerofseriousinjuryexists.
• Useonlyasuitablechargingapplianceforchargingmaintenance-freeandwet-cellbatteries.
• Donothaveanakedameorglowingobjectsnearbatteries.
• Donotgeneratesparksnearbatteries.
• Strictlynosmoking.
• Donotopenmaintenance-freebatteries.Donottopupwithdistilledwater.
• Nevertouchthebatteryterminalswithyourhandorhands.
• Thecontactsmustbecoveredtopreventshortcircuitingbymetaljumpers(e.g.hybridconnections).
• Forcleaningandmaintenance,orwhenchangingaccessoriesandspares,alwaysisolatethemachinefromthebatterybydetachingthe
battery-chargingplug.
• Themachinemustnotbecleanedusinghigh-pressureorsteamcleanersorliquidsprays.
• Withmachinesttedwithanon-boardbatterycharger,donotmodifythe230Vlines!Inparticular,donotremoveoropenanyelectrical
terminalsorremovetheearthcable.Donotoperateapplianceswithdamagedcables!
Preventing total discharge of batteries
Beforeperiodsofprolongednon-use,thebatterymustbefullychargedtoprotectitfromtotaldischarge,andthereaftertheelectricalcom-
ponentsfromthebatterymustbeisolatedbypullingthechargingplugfromthebattery.Dischargesofmorethan80%ofthenominalcapacity,
i.e.whenthebatterychargeis20%orless,areregardedastotaldischarges.Theoutcomeisashortenedbatterylifeorcompletedestruction
ofthebattery.Claimsunderguaranteeinvolvingatbatteriesordestructioncanthereforenotbevalidated.
8 MAINTENANCE AND REPAIR
Ourproductshavebeeninspectedforsafetyatthefactory.Toensuretheiroperationalsafetyandtomaintaintheirvalue,aservicemustbe
carriedoutonceeverytwelvemonthsorafter400hoursofoperation.Servicemayonlybeperformedbyourservicedepartmentorbyappro-
vedexperts.
9 TRANSPORTATION AND STORAGE
Whentransportingandstoring,thetemperaturemustnotexceed50°C.Attemperaturesbelow0°C,thewatersystemmustbeenrichedwithanti-freeze.
Whenmachineistransported,itmustbeproperlypackedandsecured.Ifthemachineisstored,thefreshwateranddirtywatermustbe
emptiedandthetankcleaned.
10 CORRECT DISPOSAL
• Packaging,unusedcleaningagentsanddirtywatermustbedisposedofinaccordancewithregulationsinforceatnationallevel.
• Returnbatteriesunopenedtothemanufacturerforprofessionaldisposal.
• Themachinemustbedisposedofafterdecommissioninginaccordancewithregulationsinforceatnationallevel.