XEMEX SCC-1 User Manual

www.xemex.eu    InstallaonManualSmartChargeController
Contents
1.INTRODUCTION        01   
 1.1 Targetgroup       01
 1.2 Intendeduse       01
 1.3 Technicalassistance      01
 1.4 Disclaimer       01
 1.5 Copyright©XEMEX      01
2.WARNINGSANDSAFETYMEASURES      02
 2.1 Key:(Meaningofsymbols)     02
 2.2 Safetyinstrucons      03
 2.3 Storageandtransport      03
3.CHECKINGTHEDELIVERY       04
 3.1 Checkingthedelivery/partsoverview    04 
 3.2 Idencaonlabel      04
4.PRODUCTDESCRIPTION       05
 4.1 Purpose,operaonandfuncon     05
 4.2 Overviewoffunconalies/conneconpoints   05
 4.3 Condionsfortheproperfunconingofthee-managementfuncon 05
 4.4 Technicalspecicaons      06
5.INSTALLATIONPREPARATIONS       07
 5.1 Installaoncondions/wiringrequirements   07
 5.2 installaonposion      07
 5.3 Overvoltageprotecon/residual-currentdevice   07
 5.4 Wiringrequirements      07
 5.5 Tooloverview       07
6.INSTALLATIONSTEPS        08
 6.1 Switchothemainswitchinthemetercupboard   08
 6.2 InstalltheSmartChargeControllerontheDINrail   08 
 6.3 ElectricalconneconstotheSmartChargeController  09
 6.4 Importantnotesconcerningtheelectricalconnecons  10
6.4.1 ACconnecons       10
 6.4.2 CTconnecons       10
 6.4.3 RequirementsforModbusRTUconnecon    10
7.COMMISSIONING        11
 7.1 Switchonthemainswitchinthemetercupboard   11
 7.2 Overviewofthecontrols/buons     11
 7.3 Menufunconsandnavigaon     12
 7.4 Commissioning       13
 7.5 Commissioninginternetpages     14
 7.5.1 Mainsconneconsengs      14
 7.5.2 Metersengs       14
 7.5.3 Wisengs       15
8.OPERATION/USE        17
 8.1 Chargingmode       17
 8.2 Currentmeasurements      18
 8.3 Sowareversions      18
 8.4 Sengs        19
 8.5 Commissioning       20
 8.6 Firmwareupdate      20
 8.7 Restoringfactorysengs      21
9.DECOMMISSIONING        22
 9.1 Switchothemainswitch/ACautomaccircuitbreaker.  22
 9.2 Dismantlingthedevice      22
10.MAINTENANCE&SERVICE       22
11.FAULTS23
12.ENVIRONMENT/WASTEDISPOSAL      23
13.DECLARATIONOFCONFORMITY      24
14.WARRANTY         24
15.CONTACT         24
www.xemex.eu    InstallaonManualSmartChargeController  pg01 
1. Introducon
Thismanualprovidestheimportantandnecessaryinformaonontheinstallaon,operaonandhandlingoftheSmartCharge
Controller,anelectronicdeviceusedinconjunconwithanEVchargingstaonthatsupportstheDynamicLoadBalancingfunc-
on.
 Pleasereadthemanualcarefullytoensurethatyouarefamiliarwithallitscontents.   
Followtheinstruconsinthemanualcarefully.Alwaysperformtheaconsinthecorrectorder.
 Thismanualshouldbekeptinasafe,dryandshadyplaceforfuturereference.Ifyoulosethismanual,youcan
requestanewcopyfrom
 thesupplier.
1.1 Target group
Theinstallaonandoperaonofthisdeviceandanymaintenancemustbecarriedoutbyaqualiedtechnicianinaccordance
withtheapplicablelocalstandardsandsafetyregulaons.
Itisimportantthatthequaliedtechnicianmeetsthefollowingrequirements:
•Knowledgeofthegeneralandspecicrulesforsafetyandaccidentprevenon.
•Extensiveknowledgeoftherelevantelectricalregulaons.
•Theabilitytoidenfyrisksandavoidpotenalhazards.
•Hasreceivedandreadtheseinstallaonandoperanginstrucons
1.2 Intended use
TheSmartChargeControllermayonlybeusedasacurrentmeterforanEVchargingstaonandonlyoperateswithinthespeci-
edvalues.
1.3 Technical assistance
Iftechnicalassistanceisrequired,pleasecontactXemexNV:
XEMEXNV
Metropoolstraat11a Tel:+322019595
B-2900Schoten  Email:support@xemex.eu
Belgium
1.4 Disclaimer
Thisdocumenthasbeenthoroughlycheckedfortechnicalaccuracypriortopublicaon.Thedocumentisregularlyupdatedand
anychangesandcorreconsareincorporatedintofutureversions.Thecontentsofthisdocumenthavebeencompiledpurelyfor
informaonpurposes.
AlthoughXemexNVhasmadeeveryeorttokeepthedocumentascorrectanduptodateaspossible,XemexNVisinnoway
liableforanydefectsanddamagesarisingfromtheuseofinformaoncontainedinthisdocument.
InnoeventshallXemexNVbeliableforanydirect,indirectorspecialdamageorconsequenallossarisingfromanyerrorsor
omissionsinthismanual.
1.5 Copyright © XEMEX
Allrightsreserved.Nopartofthispublicaonmaybereproduced,storedinaretrievalsystemortransmiedinanyformorby
anymeans,includingelectronically,mechanically,byphotocopying,recordingorotherwise,withoutthepriorwrienpermission
ofthepublisher.
PLEASE NOTE!Alwayscheckthespecicaonsandinstallaoncondionsfortheelectricalconneconsintheman-
ualofthesupplierofyourEVchargerandintheintegraondocumentoftheSmartChargeControllerandtheEV
charger.Intheeventofdoubt,alwayscontactyoursupplierandXemexNV.

XEMEX SCC-1 Specifications

General

Brand	XEMEX
Model	SCC-1
Category	Controller
Language	English