Aerco Modulex MLX-303 User Manual

MC2: 10/03/12 Page 23 of 90
AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, NY 10913 • Ph: 800-526-0288
GF-115-H
OMM-0083_0B
Modulex MLX Series Gas Fired Boiler System
Operation and Maintenance Manual
Chap 3:
Installation
3.3 Data Plate
A sample Data Plate for a Modulex Boiler is shown in Figure 3-4. The data in Table 3-1 following this
Figure indicates the required entries for each Modulex Model.
Figure 3-4: Sample Data Plate
1. TURN POWER TO THE BOILER ON AND
FOLLOW OPERATING INSTRUCTIONS FOR
THIS BOILER WHICH ARE LOCATED NEAR
THIS RATING.
IN ORDER TO START UP THE BOILER:
1) OPEN THE GAS VALVE
2) CHECK GAS AND WATER PRESSURE
3) TURN THE START UP SWITCH ON.
IN CASE THE BOILER DID NOT START
WAIT 5 MINUTES AND REPEAT THIS
PROCEDURE.
FOR PURPOSE OF
INPUT ADJUSTMENT
ELECTRICAL INPUT 115V__LESS THAN 12AMPS
ANSI Z21.13 LOW PRESSURE BOILER
CSA 4.9
PERMISSIBLE INLET GAS PRESSURE
"BLUE STAR"
Minimum relief valve capacity
MAWP, Water 50psi
Maximum Water 200°F
"BLUE FLAME"
BOILER CATEGORY
MAX.
MIN.
NORMAL MANIFOLD
PRESSURE
NORMAL
CERTIFIED BY:
UNICAL AG SPA
2. ALLOW 24 INCHES AT FRONT AND TOP FOR
SERVICING AND CLEANING.
3. FOR INSTALLATION ON COMBUSTIBLE FLOORS
FRONT
FLUE
CONN.
SIDES
1. GREATER CLEARANCES FOR ACCESS SHOULD
SUPERSEDE FIRE PROTECTION CLEARANCES.
FOR INSTALLATION ON COMBUSTIBLE FLOORS,
MINIMUM CLEARANCES TO COMBUSTIBLE
CONSTRUCTION ARE:
TOP
IN. W.C.
IN. W.C.
REAR
IN. W.C.
IN. W.C.
0 24
0
0
CLOSET
0
24
24
24
24
INPUTS 400,000
BTU/HR. OR
LESS
159 Paris Avenue, Northvale NJ 07647
SERIAL NO.
REV.
MODEL NO.
TYPE OF
GAS
MAX INPUT
MIN. INPUT
NET I=B=R RATING
OUTPUT
RATINGS-BTUH
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE OR OTHER
FLAMMABLE VAPORS AND LIQUIDS IN THE
VICINITY OF THIS OR ANY OTHER APPLIANCE.
BEFORE LIGHTING MAKE CERTAIN HOT WATER
SYSTEM IS FULL OF WATER
BTU/HR
BTU/HR
BTU/HR
BTU/HR
R
=
I
B
=
IMPORTANT
CAUTION
BTU/HR
INPUTS OVER
400,000 BTU/HR

Aerco Modulex MLX-303 Specifications

General

Brand	Aerco
Model	Modulex MLX-303
Category	Boiler
Language	English