Agria 5100 Rabbit - Troubleshooting Guide; Engine Starting and Misfiring Issues; Engine Overheating and Performance Issues

40 agria Grassland Mower 5100
6. Troubleshooting
6
6
W
Observe safety instructions! Have all serious malfunctions on the machine or
engine repaired by your agria workshop. They have the proper tools. Improper repairs
can only add to the damage.
Problem Possible cause Remedy Page
Engine - Spark plug connector not Connect spark plug connector
does not connected
start -Speed control lever not in Move speed control lever to
position CHOKE position “CHOKE” 24
- Fuel tank empty or poor fuel Fill fresh fuel 23
- Fuel line clogged Clean fuel line
- Defective spark plug Clean, adjust or exchange spark plug 34
- Engine too much fuel Dry and clean spark plug and
(“flooded engine”) start at FULL THROTTLE 33
- Inleaked air due to loose Tighten attachment bolts
caburetor and suction line
Misfirings in - Engine running in CHOKE range Move speed control-lever to operating
engine position, 24
if necessary, adjust speed control ¬ 35
- Loose ignition cable Fit connector tightly on ignition cable,
fix ignition cable retaining device,
fit connector tightly on spark plug
- Clogged fuel line or poor fuel Clean fuel line, fill fresh fuel 23
- Vent opening in fuel tank cap Exchange fuel tank cap
clogged
- Water or dirt in fuel system Drain fuel and fill fresh fuel
- Air filter clogged Clean air filter or exchange 32
- Carburetor misadjusted Re-adjust carburetor ¬ 35
Excessive - Low engine oil level Refill oil immediately 31
temperature - Impaired cooling Clean cooling fan grille, 34
in engine clean internal cooling fins ¬ 34
- Air filter clogged Clean air filter 32
- Carburetor misadjusted Re-adjust carburetor ¬ 35
Misfirings - Short firing intervals Adjust spark plug 34
in engine - Incorrect idle mix Adjust carburetor ¬ 35
at high speeds
Engine - Firing interval too long, Adjust or replace spark plug 34
frequently defective spark plug
stalls - Carburetor misadjusted Re-adjust carburetor ¬ 35
in idle - Air filter clogged Clean air filter 34
Engine does - Speed control linkages are Clean speed control linkages 35
not run clogged or jammed
smoothly