Battery Safety
Battery Safety
30 31
Battery pack refers to all original Aipas eBikes battery packs.
The safety of both our customers and our products is important to us. Our eBike batteries are
lithium-ion batteries, developed and manufactured with the latest technology. We comply with
or exceed the requirements of all relevant safety standards. When charged, these lithium-ion
batteries contain a high level of energy. If a fault occurs (which may not be detectable from the
outside), in very rare cases and under unfavorable conditions, lithium-ion batteries can catch fire.
Take care when using and charging your battery. Failure to follow the guidelines below could
damage property and/or serious injury. Contact Aipas eBikes immediately if you have any
questions regarding battery safety.
Your Aipas eBike battery must not be opened, even for repairs. There is a risk your eBike battery
could catch fire, e.g. due to a short circuit. This risk increases if an eBike battery that has already
been opened is reused at a later point in time. Do not attempt to repair an eBike battery in the
event of a fault. Have it replaced with an original Aipas eBike battery pack.
The battery is protected against deep discharge, overloading, overheating, and short-circuiting
by Electronic Cell Protection (ECP). In the event of a fault, a protective circuit switches the
battery pack off automatically.
Only use original Aipas eBike batteries for your eBike. Using other batteries can lead to injuries
and pose a fire hazard. Aipas eBikes accepts no liability or warranty claims if other batteries are
used.
To prevent serious injury or death:
Do not leave your battery unattended while charging.
When removing the battery, unplug the rubber stopper on the charging point.
Please remove the battery from the bicycle when not in use and store in a secure location to
prevent unauthorized use.
Please do not submerge the battery in liquid of any kind.
Battery charging times may increase with battery age and usage.
Only grab the charger by the plug and not the cable when plugging and unplugging from the
wall.
If the battery has trouble charging, stop charging and contact Aipas eBikes immediately.
Do not puncture or crush the battery pack. Do not impact the battery pack or modify it in any
way. Do not use the battery pack if it shows visible damage. The aforementioned can increase
the danger of fire or explosion.
Protect the battery pack from heat (e.g., temperature >140ºF), fire, and immersion in water.
The aforementioned can increase the danger of fire or explosion.
Always remove the battery pack before beginning work (e.g. inspection, repair, assembly,
maintenance, work on the chain, etc.) on your Aipas eBike, transporting it via car or airplane,
or storing it. Unintentional activation of the Aipas eBike poses a risk of injury.
Do not open the battery. There is a risk of short-circuiting. Opening the battery voids any
warranty claims.
When the battery is not in use, keep it away from paper clips, coins, keys, nails, screws, or other
small metal objects that could make a connection from one terminal to another. A short
circuit between the battery terminals may cause burns or a fire. Short circuit damage which
occurs in this instance voids any warranty claims against Aipas eBikes.
Avoid mechanical loads and exposure to high temperatures. These can damage the battery
cells and cause the flammablecontents to leak out.
Do not place the charger or the battery near flammable materials. Ensure the battery is
completely dry and placed on a fireproofsurface before charging. There is a risk of fire due to
the heat generated during charging.
Your Aipas eBike battery must not be left unattended while charging.
If used incorrectly, liquid may leak from the battery. Contact with this liquid should be avoid-
ed. If contact occurs, rinse off with water. If the liquid comes into contact with your eyes, seek
additional medical attention. Liquid leaking from the battery may cause irritation or scalding.
Batteries must not be subjected to mechanical shock. If the battery is dropped or struck with
another object, the battery may be damaged.
The battery may give off fumes if it becomes damaged or is used incorrectly. Ensure the area
is well-ventilated and seek medical attention if you experience any adverse effects. The fumes
may irritate the respiratory system.
Do not touch the terminals on your battery.
Turn the display OFF when not in use and before removing the battery pack.
Battery leakage may occur under extreme usage or temperature conditions. Avoid contact
with skin and eyes. Battery liquid is caustic and could cause chemical burns. If battery liquid
comes in contact with the skin, wash quickly with soap and water. If the liquid contacts your
eyes, immediately flush eyes with water for a minimum of 15 minutes and seek medical atten-
tion. The battery pack should not be excessively dicult to insert or remove. Do not force the
battery pack in or out of the bike frame.
To Next Page
Loading...