Axis A20 User Manual

Also snap the
locking pin
prior to placing
any kind of load
on the trailer jack. Failure to do so could result
in the trailer jack collapsing or otherwise failing,
which could lead to serious injury or death.
Failure to
properly stow
the trailer jack
in a horizontal
position and locked in place could result in dam-
age to the trailer jack that is not covered under
warranty.
 Thedrivegearandrack-and-pinionthat
control the trailer jack movement should be
periodically greased with a marine-grade
grease.Thewheelbearingsinthejackand
the coaster should also be periodically oiled
to ensure that the components continue to
operate as designed.
NEVER operate the trailer, even during daylight, with-
out verifying that the lights work properly. When the
brakes are applied, it is critical that trac following can
see that you are slowing and/or stopping by seeing the
lights come on. In the event of rain, lights are required
in most locations to tow the trailer. Even assuming you will return prior to dark, events
could occur that result in towing after dark.
 Malibu(Axis)Trailerswillintegratewithmost
towvehiclewiringharnessrequirements.Notethe
plug-in in the accompanying photo. If the harness will not connect
totheplug,contacteithertheauthorizedAxisdealerforassis-
tanceorthetowvehicle’sauthorizeddealer.Adierentharness
oranadaptermaybenecessary.Theseshouldbeinstalledonlyby
trained service technicians. Never use any harness or adapter that
isnotspeciedbythetowvehiclemanufacturerandMalibu(Axis)
Trailers.
 Thetrailerisequippedwithrunninglightsaswellastaillights/stoplights.Aswithanyelectri-
callamp,thelightswilleventuallyburnout.Asspecied,thelightshaveaverylonglifetime,but
ifanyeverceasetowork,takethetrailertoyourauthorizedMalibu-AxisTrailerdealertohave
thebulbreplaced.Iftheexteriorlenscoverisdamagedorbroken,thisshouldalsobereplaced.
Additionally, these tips can help keep the light system
working at its best:
• Checkforburnedout/brokenbulbsandlensespriorto
each use.
• Use a small amount of marine-grade grease on the
plug contacts and light-bulb base to prevent rust and
corrosion.
• Besurethegroundwire(white)isproperlyconnected
to the trailer frame at all times.
Axis
Owners
Manual
2019
Page 121
lights

Axis A20 Specifications

General

Brand	Axis
Model	A20
Category	Boat
Language	English