Bajaj Pulsar 135 LS User Manual

Periodic Maintenance / Lubrication Chart
24
33. Drive chain ‘O’ ring type (If applicable) L At every 500 Kms
34. Drive chain remove, clean, insp. & lubricate (O/H) CL, L CL, L CL, L CL, L At every 10000 Kms
35. Drive chain link lock R R R R Replace at every 10000 Kms
36. Wheel bearing (for non sealed bearings only) C, L C, L At every 20000 Kms
37. Tyre tread wear (replace if worn out till TWI limit) C, R C, R C, R C, R C, R C, R At every 5000 kms i.e. at
every service after 2nd service
38. Front fork oil R R Replace at every 20000 Kms
39. Auto choke, Thermal sensor (If applicable) C, A C, A C, A C, A C, A C, A C, A C, A At every 5000 Kms
40. TPS (If applicable) C, A C, A C, A C, A C, A C, A C, A C, A At every 5000 Kms
41. RSA - Check gas pressure (If applicable) C, A C, A At every 20000 Kms.
42. Starter clutch bush kit (If applicable) CL, R CL, R CL, R
43. Clutch switch cleaning (If applicable) CL CL CL CL
44. General lubrication L L L L L L L L
45. Swing arm pivot pin lubrication L L Lubricate at every 20000 Kms
46. Engine foundation silent bush (If applicable) R R R Replace at every 15000 Kms
RECOMMENDED FREQUENCY
Servicing
Sr.
No.
Operation
1st
750
2nd
5000
3rd
10000
4th
15000
5th
20000
6th
25000
7th
30000
Kms
C : Check, A : Adjust, CL : Clean, R : Replace, T : Tighten, L : Lubricate
Note : Parts / Lubricants to be replaced as per Periodic Maintenance and Lubrication Chart are mandatory and the same are chargeable to
customer.

Bajaj Pulsar 135 LS Specifications

General

Engine Type	4-Stroke, DTS-i, Air Cooled, Single Cylinder
Displacement	134.66 cc
Max Power	13.5 PS @ 9000 rpm
Max Torque	11.4 Nm @ 7500 rpm
Transmission	5-speed
Fuel System	Carburetor
Front Brake	240 mm Disc
Rear Brake	130 mm Drum
Fuel Tank Capacity	8 liters
Kerb Weight	122 kg
Gearbox	5-speed
Bore x Stroke	54 mm x 58.8 mm
Compression Ratio	9.8:1
Overall Length	1995 mm
Overall Width	765 mm
Overall Height	1045 mm
Wheelbase	1325 mm
Ground Clearance	165 mm
Front Suspension	Telescopic
Rear Suspension	5-way adjustable, Nitrox shock absorber
Clutch	Wet, Multi Plate
Front Tyre	2.75 x 17
Rear Tyre	100/90 x 17
Starting	Kick and Self Start