Bauer Mini Verticus - Page 9

MNL-126509
April 4, 2013 Page viii
Figure 3-29 Inlet Assembly....................................................................................................................................................... 46
Figure 3-30 Automatic Condensate Drain ................................................................................................................................ 49
Figure 3-31 ACD Operation Diagrams ..................................................................................................................................... 50
Figure 3-32 ACD System.......................................................................................................................................................... 52
Figure 3-33 ACD Valve and Manifold Assembly .................................................................................................................... 53
Figure 3-34 Condensate Collector............................................................................................................................................. 54
Figure 3-35 Condensate Collector............................................................................................................................................. 55
CHAPTER 4: - - - - - - - - - - - - - - - - PURIFICATION SYSTEM
Figure 4-1 Cartridge Safety Venting....................................................................................................................................... 57
Figure 4-2 P0 & P31 Safety Venting ...................................................................................................................................... 57
Figure 4-3 Purification System Dataplates (typical)............................................................................................................... 57
Figure 4-4 Correction Factor for Cartridge Operating Hours ................................................................................................. 61
Figure 4-5 Example Record of Adjusted Operating Hours..................................................................................................... 61
Figure 4-6 P1 Purification System .......................................................................................................................................... 63
Figure 4-7 Oil and Water Separator ........................................................................................................................................64
Figure 4-8 Oil and Water Separator Labels ............................................................................................................................65
Figure 4-9 Oil and Water Separator ........................................................................................................................................67
Figure 4-10 Sintered Metal Filter Assembly............................................................................................................................. 67
Figure 4-11 Cartridge Replacement .......................................................................................................................................... 67
Figure 4-12 P1 Purification System Parts List..........................................................................................................................69
Figure 4-13 Oil and Water Separator Parts List........................................................................................................................ 70
Figure 4-14 10” Chamber Parts List ......................................................................................................................................... 71
CHAPTER 5: - - - - - - - - - - - - COMPRESSOR DRIVE; G 120 II V
Figure 5-1 Vertical Drive with Idler (typical)......................................................................................................................... 72
Figure 5-2 G 120 II V Drive with Idler .................................................................................................................................. 73
CHAPTER 6: - - - - - - - - - - ELECTRICAL PANEL, ASY-1058 XL
Figure 6-1 ASY-1058 XL and MNR-0053 ............................................................................................................................. 75
Figure 6-2 Electrical Panel Label............................................................................................................................................ 76
Figure 6-3 PLC, CNT-0078 .................................................................................................................................................... 77
Figure 6-4 Connector Block Removal .................................................................................................................................... 77
Figure 6-5 Hourmeter.............................................................................................................................................................. 79
Figure 6-6 Transformer and Fuses .......................................................................................................................................... 79
Figure 6-7 Motor Starter (typical)........................................................................................................................................... 80
Figure 6-8 Overload Relay (typical) .......................................................................................................................................80
Figure 6-9 Power Supply......................................................................................................................................................... 81
Figure 6-10 Securus II
®
Transmitter ......................................................................................................................................... 82
Figure 6-11 High Temperature Switch......................................................................................................................................83
Figure 6-12 Pressure Sensor (Typical)...................................................................................................................................... 83
Figure 6-13 Condensate Level Float Switch ............................................................................................................................. 84
Figure 6-14 Control Pane .......................................................................................................................................................... 88
Figure 6-15 Electrical Panel, Front View.................................................................................................................................. 89
Figure 6-16 Electrical Panel, Bottom View .............................................................................................................................. 90