EasyManua.ls Logo

Bryant 986TC User Manual

Bryant 986TC
76 pages
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Page #1 background imageLoading...
Page #1 background image
Installation, Start-up, Operating,
Service and Maintenance Instructions
NOTE: Read the entire instruction manual before starting the installation.
TABLE OF CONTENTS
REQUIRED NOTICE FOR MASSACHUSETTS INSTALLATIONS2
IMPORTANT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
SAFETY CONSIDERATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Table 1 – Minimum Clearances to Combustible Materials for All Units
4
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Table 2 – Loose Parts Bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
CODES AND STANDARDS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
ELECTROSTATIC DISCHARGE (ESD) PRECAUTIONS PROCE-
DURE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
AIR FOR COMBUSTION AND VENTILATION . . . . . . . . . . . . . . 7
Table 3 – Minimum Free Area Required for Each Combustion Air
Opening or Duct to Outdoors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Table 4 – Minimum Space Volumes for 100% Combustion, Ventila-
tion and Dilution Air from Outdoors . . . . . . . . . . . . . . . . . . . . . . . 9
CONDENSATE TRAP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Condensate Drain Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Table 5 – Opening Dimensions - In. (mm) . . . . . . . . . . . . . . . . . 16
Table 6 – Air Filter Selection and Duct Sizing - In. (mm) . . . . . 18
Table 7 – Filter Media Pressure Drop (Clean) Versus Airflow - In.
W.C. (Pa) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Table 8 – Filter Media Pressure Drop (Clean) Versus Face Velocity-
In. W.C. (Pa) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
AIR DUCTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
GAS PIPING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Table 9 – Maximum Capacity of Pipe . . . . . . . . . . . . . . . . . . . . . 23
ELECTRICAL CONNECTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . 24
115-V Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Table 10 – Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
24-V Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
VENTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Table 11 – Vent Termination Kit for Direct Vent (2-pipe) Systems33
Table 12 – Maximum Allowable Exposed Vent Lengths Insulation Ta-
ble. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Table 13 – Maximum Equivalent Vent Length - Ft. . . . . . . . . . . 43
Table 14 – Deductions from Maximum Equivalent Vent Length - Ft.
(M) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Table 15 – Hanger Spacing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Table 16 – Approved Combustion-Air and Vent Pipe, Fitting and Ce-
ment Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
START-UP, ADJUSTMENT, AND SAFETY CHECK . . . . . . . . . 51
Table 17 – Cooling4 and Heating Air Delivery - CFM (Bottom Re-
turn5 with Filter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Table 18 – Altitude Derate Multiplier for U.S.A. . . . . . . . . . . . . 56
Table 19 – Blower Off Delay Setup Switch . . . . . . . . . . . . . . . . 59
Table 20 – Orifice Size and Manifold Pressure (In. W.C.) for Gas Input
Rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Table 21 – Gas Rate (CU ft./hr). . . . . . . . . . . . . . . . . . . . . . . . . . 61
SERVICE AND MAINTENANCE PROCEDURES. . . . . . . . . . . . 61
WINTERIZATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
SEQUENCE OF OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
PARTS REPLACEMENT INFORMATION GUIDE . . . . . . . . . . . 76
MODEL NOMENCLATURE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
TRAINING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Most states in the USA and jurisdictions in Canada have laws that
require the use of Carbon Monoxide (CO) alarms with fuel burning
products. Examples of fuel burning products are furnaces, boilers, space
heaters, generators, water heaters, stoves/ranges, clothes dryers,
fireplaces, incinerators, automobiles, and other internal combustion
engines. Even if there are no laws in your jurisdiction requiring a CO
Alarm, it’s highly recommended that whenever any fuel burning product
is used in or around the home or business that the dwelling be equipped
with a CO Alarm(s). The Consumer Product Safety Commission
recommends the use of CO Alarm(s). The CO Alarm(s) must be
installed, operated, and maintained according to the CO Alarm
manufacturer’s instructions. For more information about Carbon
Monoxide, local laws, or to purchase a CO Alarm online, please visit the
following website. https://www.kidde.com.
A200352
Portions of the text and tables are reprinted from NFPA 54/ANSI Z223.1E, with permission of National Fire Protection Association, Quincy, MA
02269 and American Gas Association, Washington DC 20001. This reprinted material is not the complete and official position of the NFPA or ANSI
on the referenced subject, which is represented only by the standard in its entirety.
986TC
Two-Stage, Variable-Speed, Multipoise
35 in. (889 mm) Tall, Condensing Gas Furnace
WARNING
!
CARBON MONOXIDE POISONING HAZARD
Failure to follow this warning could result in personal injury and/or
death.
Carbon Monoxide (CO) is a colorless, odorless, and tasteless poisonous
gas that can be fatal when inhaled. Follow all installation, maintenance,
and service instructions. See additional information below regarding
the installation of a CO Alarm.
Question and Answer IconNeed help?

Do you have a question about the Bryant 986TC and is the answer not in the manual?

Bryant 986TC Specifications

General IconGeneral
Model986TC
TypeGas Furnace
Efficiency RatingHigh Efficiency
Blower TypeVariable Speed
StagesModulating
AFUE RatingUp to 98.3%
Fuel TypeNatural Gas or Propane
WarrantyLifetime Heat Exchanger Limited Warranty
Parts Warranty10-Year Parts Limited Warranty

Summary

REQUIRED NOTICE FOR MASSACHUSETTS INSTALLATIONS

Important Requirements

Key requirements for gas-fueled equipment installations in Massachusetts.

SAFETY CONSIDERATIONS

Fire, Explosion, and Carbon Monoxide Hazards

General warnings about fire, explosion, electrical shock, and CO poisoning.

Furnace Reliability Hazards

Warnings regarding improper installation, adjustment, and maintenance.

Cut Hazard Warnings

Precautions for handling sheet metal parts with sharp edges.

Understanding Safety-Alert Symbols

Explanation of DANGER, WARNING, CAUTION signal words.

SAFETY AND GENERAL INSTALLATION GUIDELINES

General Furnace Installation Requirements

Key requirements for safe and proper furnace operation and installation.

Clearances to Combustible Materials

Table detailing minimum required clearances for safe installation.

IMPORTANT INSTALLATION AND START-UP PROCEDURES

Preventing Nuisance Smoke or Odor

Procedures to minimize smoke/odor complaints during initial operation.

Furnace Orientation and Pitch

Proper furnace positioning for multipoise orientations and condensate drainage.

Garage Installation Safety

Specific safety measures for installing furnaces in garages.

CODES, STANDARDS, AND ESD PRECAUTIONS

Applicable Codes and Standards

Compliance requirements for installation based on national and local codes.

Electrostatic Discharge (ESD) Precautions

Procedures to prevent damage to electronic components from static discharge.

LOCATION AND COMBUSTION AIR REQUIREMENTS

Furnace Location Considerations

Guidelines for furnace placement, including construction heating and corrosive atmospheres.

Combustion Air Requirements Overview

Introduction to air needs for direct-vent and non-direct-vent furnace configurations.

COMBUSTION AIR REQUIREMENTS

Ventilated Combustion Air Applications

Requirements for systems using ventilated combustion air.

Furnace Corrosion Hazard Prevention

Warnings about contaminants in combustion air that can cause corrosion.

Outdoor Combustion Air Method

Guidelines for providing outdoor air for combustion and ventilation.

COMBUSTION AIR VOLUME AND CONDENSATE TRAP

Air Volume Requirements - Standard Method

Procedures for calculating required air volume based on space volume and infiltration rates.

Condensate Trap Installation - Upflow and Downflow

Instructions for installing and orienting the condensate trap.

CONDENSATE TRAP CONFIGURATIONS

Upflow Trap Configuration

Steps for configuring the condensate trap in upflow orientation.

Downflow Trap Configuration

Steps for configuring the condensate trap in downflow orientation.

Horizontal Trap Configuration

Instructions for repositioning the trap in horizontal installations.

CONDENSATE DRAIN CONNECTIONS

Horizontal Drain Trap Grommet Requirement

Specific requirement for the grommet in horizontal direct-vent applications.

Condensate Drain Hazard Warnings

Warnings regarding property damage from condensate and freezing hazards.

CONDENSATE DRAIN CONNECTIONS

Relocating Condensate Trap and Drain Lines

Procedures for moving the trap and connecting drain lines.

Right Side Drain Installation Steps

Detailed steps for routing the drain line on the right side.

CONDENSATE DRAIN CONNECTIONS

Left Side Drain Routing and Modification

Steps for routing drain lines on the left side and modifying the drain elbow.

Horizontal Orientation Drain Considerations

Specific notes for drain connections in horizontal furnace installations.

INSTALLATION - SUPPLY AND RETURN AIR

Furnace Pitch and Cabinet Leakage

Requirements for furnace pitching and cabinet air leakage specifications.

Supply Air Connection Guidelines

Instructions for connecting supply air ductwork to the furnace.

Return Air Connection Configurations and Restrictions

Permitted return air connections and prohibited locations, including warnings.

INSTALLATION - RETURN AIR AND FILTERS

Bottom and Side Return Air Inlet Options

Information on bottom and side return air inlets and panel usage.

Air Filter Selection and Duct Sizing

Table for selecting air filters based on furnace size and duct dimensions.

INSTALLATION - VARIOUS CONFIGURATIONS

Downflow Installation on Combustible Flooring

Specific requirements for downflow installation on combustible flooring.

Return Air Connection Restrictions

Reinforces warnings about prohibited return air connections.

Attic Installation Property Hazard

Caution regarding property damage risks when installing in attics.

INSTALLATION - FILTERS AND DUCTWORK

Filter Arrangement and Selection Guidelines

Details on filter types, media, and cabinet selection.

Filter and Duct Sizing Considerations

Factors influencing filter and duct sizing, including pressure drop.

INSTALLATION - MEDIA FILTER EXAMPLES

Media Filter Installation Configurations

Diagrams illustrating media filter installation for various furnace sizes and return air types.

INSTALLATION - FILTER PERFORMANCE AND LEVELING

Filter Media Pressure Drop Comparison

Tables comparing pressure drop for different filter types and airflows.

Leveling Legs Installation Procedure

Steps for installing leveling legs if required for furnace stability.

INSTALLATION - DUCTWORK AND SUPPORTS

Ductwork Design and Installation Standards

General requirements and standards for designing and installing duct systems.

Furnace Support Requirements

Guidelines for platform and suspended furnace support methods.

Roll-Out Protection Installation

Requirements for installing flame roll-out protection.

GAS PIPING INSTALLATION

Working Platform and Suspended Furnace Installation

Diagrams for attic platform and suspended furnace installation setups.

Gas Piping Fire and Explosion Hazards

Critical warnings regarding gas piping installation safety.

Massachusetts Gas Piping Requirements

Specific regulations for gas piping in Massachusetts.

GAS PIPING INSTALLATION

Gas Entry Configurations and Pipe Sizing

Diagrams for gas entry and table for maximum pipe capacity.

Gas Piping Pressure Testing Procedures

Safety warnings and procedures for pressure testing gas piping.

ELECTRICAL CONNECTIONS

Electrical Safety Hazards and Warnings

General warnings covering shock, fire, explosion, and furnace operation hazards.

115-V Wiring and Electrical Specifications

Guidelines for 115-V wiring and table of electrical specifications.

ELECTRICAL CONNECTIONS

External Electrical Box Installation

Procedures for installing an external electrical box on the furnace casing.

J-Box Installation and Grounding

Instructions for installing the J-box and ensuring proper grounding.

ELECTRICAL CONNECTIONS

External Electrical Box Mounting Procedures

Steps for mounting external electrical boxes on the side and top panels.

Power Cord and BX Cable Installation in J-Box

Instructions for installing power cords and BX cable within the J-box.

ELECTRICAL CONNECTIONS

24-V Wiring and Thermostat Connections

Wiring details for 24-V circuits and thermostat connections.

Accessory Wiring Connections

How to connect accessories like EAC, humidifiers, and communication interfaces.

Alternate Power Supply Requirements

Considerations for using alternate power supplies with the furnace.

ELECTRICAL CONNECTIONS

Furnace Control Board and Wiring Diagrams

Diagrams illustrating furnace control board connections and wiring layouts.

ELECTRICAL CONNECTIONS

Thermostat Wiring Diagrams for Various Systems

Diagrams for wiring thermostats with furnaces, AC, and heat pumps.

VENTING SYSTEM INSTALLATION

Venting System Planning and Materials

Guidance on planning the venting system and approved materials.

Canada Venting Requirements

Specific venting requirements for installations in Canada.

VENTING SYSTEM INSTALLATION

Venting System Operation Checks and Hazards

Procedures for checking venting system operation and associated CO hazards.

Venting System Configurations Overview

Description of different venting system types (direct vent, ventilated, non-direct).

VENTING SYSTEM INSTALLATION

Vent Termination Support Recommendations

Guidelines for supporting vent terminations to prevent sagging or damage.

Venting System Placement Hazards

Warnings about hazards related to venting below the furnace and CO risks.

VENTING SYSTEM INSTALLATION

Direct Vent Termination Clearances

Required clearances for direct vent terminations based on codes and figures.

Vent Termination Kit Options

Information on available vent termination kits and their compatibility.

Locating Vent Terminations

Guidelines for determining optimal locations for vent terminations.

VENTING SYSTEM INSTALLATION

Non-Direct and Ventilated Combustion Air Termination

Clearances for non-direct and ventilated combustion air systems.

Direct Vent System Requirements and Hazards

Requirements and CO hazards specific to direct vent systems.

Combustion Air Pipe Attachment and Venting

Diagrams showing combustion air pipe attachment and vent pipe routing.

VENTING SYSTEM INSTALLATION

Direct Vent Termination Clearance Table

Detailed table of clearances for direct vent terminations per codes.

Venting Termination Clearance Notes

Important notes and recommendations regarding vent termination clearances.

VENTING SYSTEM INSTALLATION

Ventilation and Non-Direct Termination Clearances

Table of clearances for ventilated and non-direct vent systems.

Venting Location Considerations and Hazards

Factors influencing location choice and associated hazards like ice build-up.

VENTING SYSTEM INSTALLATION

Inside Corner Termination Guidelines

Specific requirements and clearances for vent terminations near inside corners.

VENTING SYSTEM INSTALLATION

Non-Direct Vent / 1-Pipe System Termination Requirements

Termination requirements for 1-pipe systems, including Alberta/Saskatchewan specifics.

Vent and Combustion Air Pipe Sizing

Guidelines for sizing vent and combustion air pipes and transition fittings.

Optional Combustion Air Inlet Pipe Configuration

Details on configuring the combustion air inlet pipe for moisture prevention.

VENTING SYSTEM INSTALLATION

Combustion Air Inlet Moisture Trap Installation

Steps for installing a moisture trap in the combustion air inlet pipe.

Polypropylene Venting System Guidelines

Critical warnings and instructions specific to polypropylene venting systems.

VENTING SYSTEM INSTALLATION

Venting System Length Calculations

Method for calculating total equivalent vent length, including fittings and pipe types.

Combustion Air and Vent Piping Insulation

Guidelines for insulating vent and combustion air piping in unconditioned spaces.

Near Furnace Vent Connections

Recommendations for vent pipe connections near the furnace to prevent condensate issues.

VENTING SYSTEM INSTALLATION

Vent Terminations for Ventilated Combustion Air

Diagrams showing vent terminations for ventilated systems.

Exposed Vent Lengths Insulation Table

Table specifying maximum allowable exposed vent lengths based on insulation and temperature.

VENTING SYSTEM INSTALLATION

Exposed Vent Lengths Insulation Table (Meters)

Table for exposed vent lengths in meters, accounting for insulation and temperature.

VENTING SYSTEM INSTALLATION

Maximum Equivalent Vent Length Tables

Tables providing maximum allowable vent lengths by pipe diameter, altitude, and unit size.

Vent Length Deductions for Fittings

Table detailing deductions for various elbow and tee configurations.

VENTING SYSTEM INSTALLATION

Near Furnace Vent Connections

Recommendations for vent pipe connections near the furnace.

Upflow Vent Configurations

Diagrams showing vent pipe routing for upflow furnace orientations.

VENTING SYSTEM INSTALLATION

Downflow Vent Configurations

Diagrams showing vent pipe routing for downflow furnace orientations.

Horizontal Vent Configurations

Diagrams showing vent pipe routing for horizontal furnace orientations.

VENTING SYSTEM INSTALLATION

Horizontal Vent Configurations Details

Diagrams and notes for horizontal vent configurations.

Vent Pipe and Combustion Air Pipe Adapter Installation

Procedures for installing vent and combustion air pipe adapters, including safety warnings.

VENTING SYSTEM INSTALLATION

Vent Coupling and Adapter Installation

Steps for assembling vent coupling and adapter with gaskets.

Polypropylene Venting System Warnings and Guidelines

Critical warnings and instructions specific to polypropylene venting systems.

VENTING SYSTEM INSTALLATION

Vent Pipe Hanger Spacing Requirements

Table specifying hanger spacing for different vent pipe materials and diameters.

Optional Vent Pipe Installation Technique

Alternative method for installing vent pipes using adapters.

Roof Termination Guidelines

Recommendations for installing vent terminations on roofs.

VENTING SYSTEM INSTALLATION

Concentric Vent Termination Procedures

Steps for installing concentric vent terminations, including warnings.

2-Pipe and Single-Pipe Termination Guidelines

Instructions for terminating 2-pipe and single-pipe systems.

Sidewall Termination Recommendations

Guidance for sidewall terminations, including support and recirculation avoidance.

Inducer Outlet Restrictor Requirement

Information on when an inducer outlet restrictor is needed.

VENTING SYSTEM INSTALLATION

Approved Venting System Materials Table

Table listing approved pipes, fittings, primers, solvents, and cements for venting.

Venting System Length Calculation Example

Example calculation for determining total equivalent vent length.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Venting System Length Calculation Example 2

Second example calculation for venting system length with specific parameters.

Important Installation and Start-up Procedures

Essential steps for initial furnace installation and start-up.

Unit Operation Hazard - Limit Switch

Caution regarding the limit switch and potential hazards.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Furnace Setup Switches Overview

Explanation of DIP switch functions for configuring furnace operation.

Cooling and Heating Air Delivery Tables

Tables showing CFM delivery for cooling and heating based on settings.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Cooling and Heating Air Delivery Tables (Continued)

Continuation of tables detailing furnace airflow rates for various conditions.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Cooling and Heating Air Delivery Tables (Continued)

Final part of tables showing furnace airflow rates for different settings.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Setup Switch Functions Explained

Detailed explanation of each setup switch (SW1-SW4) for furnace configuration.

Condensate Trap Priming Procedure and Hazards

Steps for priming the condensate trap and related safety warnings.

Purge Gas Lines Procedure

Instructions for purging gas lines after connections are made.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Gas Piping Fire and Explosion Hazard Warning

Critical safety warnings related to gas piping.

Manifold Pressure Adjustments for Altitude and Gas Heating Value

Guidance on adjusting manifold pressure considering altitude and gas heating value, including derate tables.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Checking Inlet Gas Pressure

Procedure for checking the furnace's inlet gas pressure.

Adjusting Manifold Pressure for Input Rate

Steps for adjusting manifold pressure and burner orifices for proper input rate.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Clocking the Meter for Input Rate Verification

Method for verifying furnace input rate by clocking the gas meter.

Adjusting Temperature Rise and Furnace Hazards

Procedure for adjusting temperature rise and associated furnace hazards.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Blower Off Delay Adjustment

Setting the blower off delay time for heating modes.

Cooling Airflow and Continuous Fan Adjustment

Adjusting blower speeds for cooling and continuous fan modes.

Thermostat Heat Anticipator Adjustment

Procedure for adjusting the thermostat's heat anticipator using an ammeter.

Checking Safety Controls

Steps for verifying the proper function of safety controls.

START-UP, ADJUSTMENT, AND SAFETY CHECK

Orifice Size and Gas Rate Tables

Tables for selecting orifices and determining gas rates based on pressure and altitude.

SERVICE

Service Safety Hazards and Warnings

Critical warnings for personnel performing service on the furnace.

LED Status Codes and Component Testing

Interpreting LED status codes and performing component self-tests.

SERVICE

Environmental and Electrical Safety Precautions

Safety measures regarding environmental hazards and electrical safety during service.

Troubleshooting Guide and Fault Code Retrieval

Using the troubleshooting guide and retrieving stored fault codes for diagnostics.

SERVICE

Blower Door Switch Safety During Service

Safety precautions related to the blower door interlock switch during service.

Flammable Material Storage Warning

Warning against storing flammable materials near the furnace.

Periodic Maintenance and Filter Cleaning

Recommended periodic maintenance tasks, including filter cleaning.

SERVICE

Blower Motor and Wheel Maintenance Procedures

Steps for cleaning and maintaining the blower motor and wheel.

SERVICE

Blower Assembly Removal and Cleaning

Procedures for removing and cleaning the blower assembly.

Burner and Flame Sensor Cleaning Procedures

Steps for cleaning burners and the flame sensor, including safety warnings.

SERVICE

Hot Surface Igniter Servicing and Resistance Check

Procedures for servicing the hot surface igniter, including resistance checks.

Collector Box and Drainage System Flushing

Steps for flushing the collector box and drainage system, including electrical safety warnings.

SERVICE AND WINTERIZATION

Heat Exchanger Cleaning and Secondary Heat Exchangers

Procedures for cleaning heat exchangers and considerations for secondary exchangers.

Wiring Diagrams Reference

Reference to wiring diagrams for service.

WINTERIZATION

Unit and Property Damage Hazard During Winterization

Warnings about potential damage during winterization if procedures are not followed.

WINTERIZATION

Winterization Procedure Steps

Detailed steps for winterizing the furnace using propylene glycol.

TROUBLESHOOTING GUIDE

Troubleshooting Flowchart and Status Codes

Guide for diagnosing furnace issues based on status codes and flowchart.

TROUBLESHOOTING GUIDE

Troubleshooting Guide - Control Circuitry and Pressure Switches

Flowchart steps related to control circuitry and pressure switch diagnostics.

TROUBLESHOOTING GUIDE

Troubleshooting Guide - Blower Motor and Control Issues

Flowchart steps for diagnosing blower motor and control board problems.

SEQUENCE OF OPERATION

Two-Stage Heating with Single-Stage Thermostat

Description of the heating sequence when using a two-stage furnace with a single-stage thermostat.

SEQUENCE OF OPERATION

Cooling Mode Operation with Thermostats

Sequences for single-speed and two-speed cooling modes with various thermostat types.

Dehumidification Mode Operation

How the furnace operates in dehumidification mode.

SEQUENCE OF OPERATION

Super-Dehumidify and Continuous Blower Modes

Sequences for super-dehumidify and continuous blower modes.

Heat Pump Operation Sequence

Sequence of operation when the furnace is used with a heat pump.

Component Self-Test Procedure

Steps for running the furnace's component self-test.

ELECTRICAL DIAGRAMS

Connection Diagram

Wiring diagram showing external connections to the furnace.

Schematic Diagram

Internal wiring schematic of the furnace control system.

PARTS REPLACEMENT AND TRAINING

Parts Replacement Information Guide

Guide to identifying and ordering replacement parts for the furnace.

Model Nomenclature Explanation

Breakdown of the furnace model number and its components.

Professional Training Resources

Information on accessing HVAC training resources.

Related product manuals