Need help?Do you have a question about the BYD EPS14P and is the answer not in the manual?
Describes safe operation procedures and regulations for BYD electric forklifts.
Details pre-shipment checks and delivery inspection procedures for forklifts.
Requirements for operators and company responsibilities for forklift operation.
Lists critical safety warnings and prohibitions for operating forklifts.
Lists potential hazards and precautions for forklift operators.
Provides operational cautions for forklift operators.
Explains the importance of warning decals and signs for forklift safety.
Illustrates and labels the main parts of the BYD electric forklift.
Introduces the section detailing the forklift's technical data.
Lists detailed technical specifications of the BYD electric forklift.
Describes operating conditions and associated cautions for the forklift.
Explains the forklift and battery identification plates and their information.
Explains how load capacity decreases with increasing lift height.
Demonstrates how to read and use the forklift's load capacity chart.
Refers to paying attention to additional warning decals on the forklift.
Covers key switch operation and emergency disconnect functions.
Describes the usage of the fork carriage and operational pedals.
Details how to drive, steer, and brake the forklift.
Explains how to engage the forklift's low-speed mode.
Instructions on how to operate the forklift's forks.
Explains the function of the horn and emergency reversal switch.
Details the A-type display screen and its indicators.
Details the B-type display screen and light ring.
Steps for loading the forklift onto a load.
Safe practices for traveling with a load on the forklift.
Steps for unloading the forklift from a load.
Steps for safely exiting the forklift after operation.
Instructions on how to charge the forklift battery.
Instructions on how to lift the forklift using hoisting equipment.
Procedure for driving the forklift onto a transport vehicle.
Procedures for transporting and unloading the forklift.
Steps for putting the forklift into storage.
Steps for taking the forklift out of storage and restarting.
Daily inspection checklist and content descriptions.
Defines inspection frequency and scope for daily checks.
Details what to check during daily forklift maintenance.
Regular inspection and maintenance schedule for the forklift.
Defines inspection intervals and items for regular checks.
Details the checks required for regular forklift maintenance.
Lists required consumable items and their parameters.
Preparations and procedures before performing maintenance.
General steps to take before starting maintenance on the forklift.
Procedure to lower forks in case of a vehicle fault.
Procedure for manual movement during electric faults.
Maintenance procedures for the forklift's chassis system.
How to inspect and adjust the forklift's balance.
Steps to replace the forklift's load wheels.
Steps to replace the forklift's caster wheels.
Steps to replace the forklift's drive wheels.
How to check the gear oil level in the forklift.
Steps to replace the gear oil in the forklift.
Maintenance procedures for the forklift's mast system.
How to adjust the mast lift chains.
How to lubricate the forklift's mast chains.
Instructions on how to clean the forklift's mast.
How to adjust the mast clearance.
Detailed steps for adjusting mast clearance.
Maintenance procedures for the forklift's hydraulic system.
How to fill the hydraulic oil in the forklift.
Steps to replace the hydraulic oil in the forklift.
Maintenance procedures for the forklift's electric system.
How to inspect electrical wiring on the forklift.
How to inspect the forklift's main controller.
How to inspect low voltage fuses and relays.
How to check the torque of mast fasteners.
Diagram of the forklift's electrical system.
Lists fault codes and their recommended inspections.
Diagram of the forklift's hydraulic system.
Lists contact details for BYD importers and manufacturer worldwide.
General| Rated Capacity | 1400 kg |
|---|---|
| Load Center Distance | 500 mm |
| Lifting Height | 3000 mm |
| Overall Height (Mast Lowered) | 1990 mm |
| Fork Length | 1070 mm |
| Lifting Speed (laden/unladen) | 0.3/0.45 m/s |
| Wheel Type | Solid |
To Next Page
