Carrier 62X Series - Fig. 99 - Typical Wiring Diagram (cont)

72
Fig. 99 — Typical Wiring Diagram (cont)
326
WIRING DIAGRAM #62X w/ERVWD | 62 XM18TDJDGJGHBGZF | 46 0-3-60 | S HEE T 6 OF 7 | 06/01/21 DWN
SRF
CHK
LWF
.
327
328
329
330
331
332
333
334
335
336
337
338
339
340
341
342
343
344
345
346
347
348
349
350
351
352
353
354
355
356
357
358
359
360
361
362
363
364
365
366
367
368
369
370
371
372
373
374
375
376
377
378
379
380
381
382
383
384
385
386
387
388
389
390
FIELD POWER SUPPL Y 208 /230 /4 60/57 5-3-60. M INIMUM CIRCUIT AMPACITY AND
MAXIMUM SIZE AND TYPE OF BRANCH-CIRCUIT SHORT-CIRCUIT AND GROUND-FAULT
PROTECTION PER UNIT RATING PLATE. PROVIDE DISCONNECTING MEANS AS REQUIRED.
TYPICAL MOTORS AND COMPRESSORS SHOWN. SEE CONNECTION DIAGRAM ON MOTOR
OR COMPRESSOR FOR ACTUAL WIRING DETAIL.
SET TIME DELAY PERIOD TO 5-MINUTE S. UPON INITIAL APPLICATION OF POWER TO "TD",
CONTACTOR "CC" IS ENERGIZES AFTER A 5-MINUTE START DELAY. WHEN POWER IS
REMOVED, A LOCKOUT CONDITION AND 5-MINUTE TIME DELAY PERIOD (ADJUSTABLE) IS
INITIATED. DURING THIS PERIOD, CONTACTOR "CC" CANNOT BE ENERGIZED.
FUSE NO. CLASS VAC AMPS-208/230V AMPS-460V XFMR TIME DELAY
CC 600 3 2 350VA YES
CC 600 2 1.5 250VA YES
CC 600 2 1.5 200VA YES
CC 600 1.5 3/4 150VA YES
F2, F9, F10 CC 600 1 1 N/A YES
CC 600 16 16 350VA YES
CC 600 10 10 250VA YES
CC 600 10 10 200VA YES
CC 600 6 6 150VA YES
CB
FUSE TABLE
F1, F3
2
1
5
ABBREVIATION COLOR
BK BLACK
BL BLUE
BR BROWN
GGREEN
OORANGE
PK PINK
PR PURPLE
RRED
WWHITE
YYELLOW
WIRE COLOR LEGEND
NOTE: NUMBER PLACED AFTER DASH
FOLLOWING COLOR CODE INDICATES WIRE
GAGE. EX. - BK-12 IS A BLACK, 12 AWG WIRE.
NO NUMBER AFTER COLOR CODE INDICATES 18
AWG WIRE. EX. - BK IS A BLACK 18 AWG WIRE.
FACTORY WIRING NORMALLY OPEN CONTACTS
FIELD WIRING NORMALLYCLOSED CONTACTS
EARTH GROUND IDENTIFIABLE TERMINAL
CHASSIS (PANEL) GROUND
COIL
SYMBOL LEGEND
NON-IDENTIFIA BLE TERMINAL,
OTHER WIRE JUNCTIONS,
INCLUDING SCHEMATIC
FACTORY WIRING NORMALLY OPEN CONTACTS
FIELD WIRING NORMALLYCLOSED CONTACTS
EARTH GROUND IDENTIFIABLE TERMINAL
CHASSIS (PANEL) GROUND
COIL
SYMBOL LEGEND
NON-IDENTIFIA BLE TERMINAL,
OTHER WIRE JUNCTIONS,
INCLUDING SCHEMATIC
ITEM FUNCTIONAL DESIGNATION
LINE
NUMBER
DESCRIPTION
101 CC1 100 Compressor Contactor no. 1
102 CC1-AUX1 # CC1 - Auxiliary Contact no. 1
103 CC1-CS 2,298 Compressor #1 - Current Switch
104 CC2 119 Compressor Contactor no. 2
105 CC2-AUX1 # CC2 - Auxiliary Contact no. 1
106 CC2-CS 12,304 Compressor #2 - Current Switch
107 EF-CS 48,294 Exhaust Fan - Current Switch
108 EFR 149 Exhaust Fan Relay
109 EFVFD1 45,47,217 Exhaust Fan - Variable Frequency Drive #1
110 EGB 4 Equipment Grounding Bar
111 HPR1, HPR2 98, 117 High Pressure Relay #1, #2
112 HR 179,448 Heat Relay
113 MSP-CC1 1 Motor Starter Protecon - CC1
114 MSP-CC2 11 Motor Starter Protecon - CC2
115 MSP-EF1 47 Motor Starter Protecon - Exhaust Motor #1
116 MSP-OF1 22 Motor Starter Protecon- Outdoor Fan no. 1
117 MSP-OF2 26 Motor Starter Protecon- Outdoor Fan no .2
118 MSP-OFVFD1 22 Motor Starter Protecon- OFVFD1
119 MSP-SF1 39 Motor Starter Protecon - Supply Motor #1
120 MSP-WM 55 Motor Starter Protecon - Wheel Motor
121 OFVFD1 10,22 Outdoor Fan VFD #1
122 PDB 1,391 Power Distribuon Block
123 PM
59,68,68,71
Power/Phase Monitor
124 RHR 153 Reheat Relay
125 SF-CS 40,296 Supply Fan - Current Switch
126 SFR 146 Supply Fan Motor Relay
127 SFVFD1 31,39,215 Supply Fan - Variable Frequency Drive #1
128 VRA1 15 Voltage Regulator Assembly #1
129 WM-CS 57,292 Wheel Motor - Current Sensor
130 WMR 175 Wheel Motor Relay
131 WMVFD 55,59,223 Wheel Motor Variable Frequency Drive
LEGEND - ITEMS INSIDE CONTROL PANEL
# SEE LINE NUMBER TO THE RIGHT OF CONTACTOR COIL ON WIRING DIAGRAM.
ITEM
FUNCTIONAL
DESIGNATION
LINE NUMBER DESCRIPTION
101 BCTL 179,449 Blower Compartment Thremal Limit
102 BOS1 134 Bleed Off Solenoid #1
103 CCH1 4 Crankcase He ater #1
104 CCH2 14 Crank Case Heater #2
105 CM1 2 Compressor Motor No.1
106 CM2 12 Compressor Motor No.2
107 EFM1 48 Exhaust Fan Motor #1
108 HP1 98 High Pressure Switch #1
109 HP2 117 High Pressure Switch #2
110 LP1 300 Low Pressure Switch #1
111 LP2 306 Low Pressure Switch #2
112 MRV1 155 Modulang Reheat Valve #1
113 OADA 187,290 Outside Air Damper Acuator
114 OFM1 23 Outdoor Fan Motor #1
115 OFM2 27 Outdoor Fan Motor #2
116 SFM1 40 Supply Fan Motor #1
117 UNL.SOL 1 96 Unloader Solenoid #1
118 WBDA-O 173 Wheel Bypass Damper Acuator - OA
119 WBDA-R 174 Wheel Bypass Damper Acuator - RA
120 WM 56 Wheel Motor
LEGEND - ITEMS OUTSIDE CONTROL PANEL
8
WRAP WIRE THREE TIMES THRU CURRENT SENSOR IF WIRE IS 14 GAUGE. WRAP WIRE TWO
TIME S THRU CURRENT SENSRO IF WIRE IS 12 GAUGE.