Charmglow 720-0677 User Manual (English)

Questions and Answers:

A
Amanda LopezJul 30, 2025
What to do if my Charmglow 720-0677 has excessive flare-ups?
- W
  wendybowersJul 30, 2025
  To prevent excessive flare-ups with your Charmglow Grill: * Keep the hood up while grilling. * Maintain low knob settings. * If needed, turn off one burner. * Preheat the grill for 10-15 minutes to burn off drippings. * Opt for meats with less fat. * When grilling chicken, start meat-side down on low for 20 minutes, then skin-side down for another 20 minutes, following the steps above. * If flare-ups persist, move food to the warming rack until the flames subside. Never use water on gas flames, as it can damage your grill.
C
Cody RoseAug 3, 2025
How to fix a Charmglow 720-0677 Grill that will not light?
- K
  Kimberly DavisAug 4, 2025
  If your Charmglow Grill won't light: 1. Push and turn the knob, and check for sparks. 2. If there's a spark, ensure gas is reaching the burner. Try the following: * Purge any trapped air from the gas line. * Attempt to light the burner with a match. * Verify that other burners are working correctly. * Visually inspect the electrode and wire while pushing the igniter knob. If a spark occurs anywhere other than the igniter tip, the igniter needs replacement.
M
Melissa BrightAug 7, 2025
Why is my Charmglow Grill not hot enough when the knob is on high?
- D
  Danielle CantuAug 8, 2025
  If your Charmglow Grill generates low heat even with the knob in the “HI” position: 1. First, check if the issue is isolated to a single burner. If so, clean the orifice and burner, removing any obstructions from the ports. 2. Inspect the fuel hose for bends or kinks. 3. Ensure the air shutter is properly adjusted. 4. Check for adequate gas supply and pressure. 5. Preheat the grill for a full 15 minutes. 6. If you're using LP gas, verify that the tank isn't empty.
H
Heather HoltAug 12, 2025
What to do if the burner keeps blowing out on my Charmglow Grill?
- J
  Jonathan KingAug 12, 2025
  If the burner on your Charmglow Grill keeps blowing out, try the following: 1. Inspect the burner for any defects. 2. Ensure the burner is installed correctly. 3. Make sure the fuel mixture isn't too lean. 4. Verify that the gas supply is sufficient. 5. Check if the LP tank is empty.
T
Teresa MontgomeryAug 16, 2025
Why does my Charmglow Grill have a yellow flame and a gas odor?
- D
  Daniel LutzAug 16, 2025
  If the burner flame on your Charmglow Grill is yellow and there's a noticeable gas odor: 1. Inspect the burner inlet for any obstructions, especially spiders or insects. 2. Check the air shutter to ensure it's properly adjusted. 3. Look for the source of any gas leaks.
M
michaelmurrayAug 20, 2025
How to increase the heat on my Charmglow 720-0677 using LP gas?
- J
  Jonathan CooperAug 20, 2025
  To address low heat issues with your Charmglow Grill when using LP gas: 1. Ensure all burner valves are in the 'OFF' position. 2. Open the tank valve and wait for 5 seconds. 3. Light the burners one at a time, following the lighting instructions.
D
douglasbanksAug 25, 2025
What size gas line do I need for my Charmglow Grill using natural gas?
- M
  matthew24Aug 25, 2025
  To address low heat issues with your Charmglow Grill when using natural gas, adhere to the recommendations outlined in the chart below concerning the distance from your house to the grill and the appropriate tubing size: From House to Grill Distance | Tubing Size ---|--- Up to 25' | 3/8" diameter 26' -50' | 1/2" diameter 51' -100' | 2/3" of run 3/4" 1/3" of run 1/2".

Charmglow 720-0677 Specifications

General

Fuel Type	Propane
Number of Burners	4
Ignition Type	Electronic
Material	Stainless Steel
BTUs	48000

Summary

Safety Information

Hazard Definitions & General Warnings

Defines WARNING/CAUTION levels and covers initial warnings for lighting, gas odor, pressure testing, damaged equipment, and leak testing.

Installation & Storage Safety

Covers safety concerns related to enclosures, LP tank size, use in recreational vehicles, and indoor storage.

Safety Information

Operational Safety Precautions

Details safety for unattended cooking, burner placement, match lighting, spiders, cleaning, rotisserie use, and grill weight.

Gas Cylinder Handling

Provides warnings for LP gas cylinder storage, filling limits, and Overfill Prevention Devices (OPD).

Safety Information

General Use Safety Practices

Outlines practices for child safety, flammable material clearance, apparel, utensils, hot surfaces, grease management, lid opening, and lighting.

Environmental & Health Warnings

Addresses warnings about indoor use and California Proposition 65 concerning combustion by-products.

Safety Information

Usage Restrictions & Warnings

Warns against aluminum foil use, discusses burner cleaning, cylinder condition, cleaners, fatty meats, construction clearances, briquettes, and wind.

Placement of the Grill

Clearance Requirements

Specifies minimum clearances from combustible materials and overhead structures for safe grill placement.

Location Considerations

Discusses factors like ventilation, wind exposure, and proximity to traffic paths for optimal placement.

Package Contents List

Main Grill Components

Lists parts A-F: Main Cart Grill, Side Burner Lid, Bottle Opener, Bottom Panel, Swivel Caster, Left Side Panel.

Package Contents List

Grill Body & Lids

Lists parts G-J: Side Panels, Back Panel, Firebox, and Grill Lid.

Functional Parts & Hardware

Lists parts K-U: Cranks, Trays, Drawer components, Push Bar, and Griddle.

Hardware Contents

Screw and Nut Hardware

Details hardware packs AA through EE, including various screws and nuts.

Washer and Battery Hardware

Details hardware packs FF through II, including washers and a battery.

Preparation for Assembly

Parts Verification

Instructions to check all parts against the contents list before beginning assembly.

Assembly Time & Tools

States the estimated assembly time and lists the tools required for the process.

Assembly Orientation Note

Clarifies the designation of left and right sides relative to the user's perspective.

Assembly Instructions

Griddle Assembly

Step-by-step guide for assembling the griddle onto the grill.

Assembly Instructions

Side Burner Lids Assembly

Instructions for attaching the two side burner lids to the grill.

Bottle Opener Assembly

Steps for attaching the bottle opener to the left side of the grill.

Swivel Caster Assembly

Guide for mounting the swivel casters onto the bottom panel of the grill cart.

Assembly Instructions

Side Panel Assembly

Instructions for attaching the left and right side panels to the bottom panel.

Back Panel Assembly

Details on attaching the back panel to the bottom and side panels.

Assembly Instructions

Firebox Assembly

Instructions for positioning and securing the firebox assembly onto the grill cart.

Assembly Instructions

Charcoal Lid Assembly

Steps for attaching the charcoal grill lid to the firebox using specified hardware.

Charcoal Grill Attachment

Instructions for connecting the charcoal grill unit to the main grill.

Assembly Instructions

Charcoal Drawer Handle Assembly

Guide for attaching the handle to the large drawer front panel.

Charcoal Tray and Drawers Assembly

Instructions for inserting the charcoal tray and drawers into their respective glides.

Assembly Instructions

Charcoal Handle Installation

Steps for screwing the charcoal grill handle into the charcoal door.

Push Bar Installation

Instructions for attaching the push bar to the side panels of the charcoal grill.

Assembly Instructions

Side Shelf Tray Installation

Guide for placing the side shelf tray onto the installed push bar.

Lamp Wire Installation

Instructions for connecting the lamp wire from the charcoal grill light.

Assembly Instructions

Liquid Propane Tank Tray Assembly

Steps to install the tank tray and secure the LP tank within the grill cart.

Assembly Instructions

Battery Installation

Guide for inserting the battery into the ignition button housing.

Liquid Propane Hook-Up

Instructions for connecting the regulator assembly to the LP cylinder.

Installation Instructions

Gas Hook-Up Procedure

General guidelines and manufacturer recommendations for connecting the gas supply.

Gas Consumption Rates

Lists the total gas consumption (BTU/Hr) for all burners operating at maximum.

Installation Code Compliance

Mentions adherence to national and local gas and electrical installation codes.

Installation Instructions

Liquid Propane Cylinder Requirements

Details specifications for 20-lb LP cylinders, including DOT standards and valve types.

Connecting the LP Cylinder

Step-by-step instructions for safely connecting the LP gas cylinder to the grill.

Disconnecting the LP Cylinder

Procedure for safely disconnecting the LP gas cylinder from the grill.

Installation Instructions

Leak Testing Procedure

Instructions for performing an initial leak test and checks before each use.

Installer Final Check

A checklist of final checks for the installer before operating the grill.

Operating Instructions

General Grill Usage

Overview of basic grill operation, features, and cooking area.

Grilling Techniques

Advice on searing, browning, and adjusting heat settings for optimal food preparation.

Preheating Procedure

Steps and recommended duration for preheating the grill before cooking.

Operating Instructions

Rear Burner Operation

Describes the function and use of the rear burner, including rotisserie cooking.

Infrared Searing Burner

Explains the purpose and usage of the infrared searing main burner for quick searing.

Lighting Preparations

Covers inspecting the gas hose and regulator before attempting to light the grill.

Lighting Main Burners

Detailed steps for lighting the main burners using the igniter or match.

Lighting Searing/Rear Burners

Instructions for lighting the searing and rear burners via igniter or match.

Lighting Side Burner

Steps for lighting the side burner using the igniter or match.

Operating Instructions

Manual Lighting Procedure

General steps for lighting any burner using a match and lighting rod.

Main Burner Manual Lighting

Specific instructions for manually lighting the main burner with a match.

Operating Instructions

Searing/Side Burner Manual Lighting

Specific instructions for manually lighting the searing and side burners with a match.

Rear Burner Manual Lighting

Specific instructions for manually lighting the rear burner with a match.

Halogen Lights Operation

Light Operation

Basic instructions for turning the halogen lights on and off.

Bulb Replacement Safety

Safety precautions to follow before replacing a halogen bulb in the light fixture.

Halogen Lights Operation

Halogen Bulb Replacement Steps

Detailed step-by-step guide for replacing the halogen bulb.

Light Fixture Cleaning

Instructions for cleaning the glass cover of the halogen light fixture.

Electrical Safety for Lights

Electrical safety guidelines for operating and cleaning the halogen lights.

Gas Conversion from LP to NG

Conversion Warning

Crucial safety warning to ensure knobs and cylinder valve are OFF before conversion.

Conversion Overview

Explains the process, parts required, and warranty implications of converting the grill.

Orifice Size and BTU Chart

Provides a chart detailing orifice sizes and BTU ratings for LP and NG gas.

Required Conversion Tools

Lists the necessary tools, such as screwdrivers and nut drivers, for the conversion.

Gas Conversion from LP to NG

NG Regulator Installation

Step-by-step instructions for installing the NG regulator and bracket on the grill.

Gas Conversion from LP to NG

Main Tube Burner Orifice Replacement

Instructions for removing LP orifices and installing NG orifices in the main tube burners.

Gas Conversion from LP to NG

Searing Main Burner Orifice Replacement

Steps to replace the LP orifices with NG orifices on the searing main burner.

Gas Conversion from LP to NG

Question Mark Burner Orifice Replacement

Guide for replacing orifices on the question mark side burner for NG conversion.

Gas Conversion from LP to NG

Side Burner Orifice Replacement

Instructions for replacing the LP orifices with NG orifices on the side burner.

Rear Burner Orifice Replacement

Steps to replace the LP orifices with NG orifices on the rear burner.

Gas Conversion from LP to NG

Burner Flame Adjustment

Guidance on adjusting burner flame height after conversion for optimal performance.

Conversion Technician Advice

Recommends consulting a gas supplier or trained technician for conversion.

Limited Warranty Information

Warranty Coverage Details

Outlines specific warranty periods for parts like burners, grids, and stainless steel components.

Warranty Exclusions

Lists items not covered by the warranty, such as cosmetic issues, misuse, and accidents.

Warranty Limitations

Discusses implied warranties, limitations on remedies, and consequential damages.

Contacting Customer Service

Provides contact information for warranty claims, parts orders, and general support.

Replacement Parts List

Grill Main Components Parts

Lists part numbers and descriptions for primary grill components, from Temperature Gauge to Side Burner Valve.

Grill Accessories & Other Parts

Lists part numbers for accessories and other components, from Door Magnet to Lighting Rod.

Replacement Parts List

Charcoal Grill Components

Lists part numbers for charcoal grill components, from Drawer w/ panel, small to Push bar support bracket, rear.

Charcoal Grill Accessories

Lists part numbers for charcoal grill accessories and components, from Push bar to Cooking grid with hole.

Related product manuals

Charmglow GRILL 720-0230

Charmglow 5 Burner Gas Grill

64 pages

Charmglow Gourmet Luxury

64 pages

Charmglow 720-0677 User Manual

Table of Contents

Questions and Answers:

Charmglow 720-0677 Specifications

Summary

Safety Information

Hazard Definitions & General Warnings

Installation & Storage Safety

Safety Information

Operational Safety Precautions

Gas Cylinder Handling

Safety Information

General Use Safety Practices

Environmental & Health Warnings

Safety Information

Usage Restrictions & Warnings

Placement of the Grill

Clearance Requirements

Location Considerations

Package Contents List

Main Grill Components

Package Contents List

Grill Body & Lids

Functional Parts & Hardware

Hardware Contents

Screw and Nut Hardware

Washer and Battery Hardware

Preparation for Assembly

Parts Verification

Assembly Time & Tools

Assembly Orientation Note

Assembly Instructions

Griddle Assembly

Assembly Instructions

Side Burner Lids Assembly

Bottle Opener Assembly

Swivel Caster Assembly

Assembly Instructions

Side Panel Assembly

Back Panel Assembly

Assembly Instructions

Firebox Assembly

Assembly Instructions

Charcoal Lid Assembly

Charcoal Grill Attachment

Assembly Instructions

Charcoal Drawer Handle Assembly

Charcoal Tray and Drawers Assembly

Assembly Instructions

Charcoal Handle Installation

Push Bar Installation

Assembly Instructions

Side Shelf Tray Installation

Lamp Wire Installation

Assembly Instructions

Liquid Propane Tank Tray Assembly

Assembly Instructions

Battery Installation

Liquid Propane Hook-Up

Installation Instructions

Gas Hook-Up Procedure

Gas Consumption Rates

Installation Code Compliance

Installation Instructions

Liquid Propane Cylinder Requirements

Connecting the LP Cylinder

Disconnecting the LP Cylinder

Installation Instructions

Leak Testing Procedure

Installer Final Check

Operating Instructions

General Grill Usage

Grilling Techniques

Preheating Procedure

Operating Instructions

Rear Burner Operation

Infrared Searing Burner

Lighting Preparations

Lighting Main Burners

Lighting Searing/Rear Burners