CITROEN C2 2004 - Page 308

To Next Page

To Previous Page

304

CLUTCH

GEARBOX

TRANSMISSION

MA/5 GEARBOX

Engines: KFW - NFU

«a» Identification label.

«b» Location for engraving of serial and gearbox nos.

B2CP3HTC

XSARA

Main Page

Presentation2
Reconnect Battery after Vehicle Repair4
Identification of Vehicles5
Operations to be Carried Ort after a Repair8
Antiscanning Function8
Tailgate8
Overspeed Check8
Capacities (in Litres)34
Draining Mandhod34
Lubricants - Total Recommended Oils42
Engine Oil Consumption66
Engine Specifications67
Special Features - Tightening Torques71
Tightening Torques: Power Unit Suspension82
Cylinder Head100
Identification of Cylinder Head Gasket100
Cylinder Head Tightening (M.dan)101
Cylinder Head Bolts101
Belt Tension/Seem Units Correspondence Table118
Auxiliary Equipment Drive Belt119
Auxiliary Equipment Drive Belt 2002121
Recommendations: Timing Belt151
Checking and Setting the Valve Timing152
Special Features of the Timing229
Valve Clearance Settings230
Checking the Oil Pressure231
Oil Filters234
Filling and Bleeding the Cooling Circuit235
Idling - Depollution236
Petrol Injection237
Depollution Technical Checks (France)240
Emission Standards241
Safety Requirements: Hdi Direct Injection System247
Prohibited Operations: Siemens Hdi Direct Injection System249
Prohibited Operations: Delphi Hdi Direct Injection System251
Prohibited Operations: Hdi Direct Injection System253
Specifications of the Delphi Diesel Injection Pump256
Checking and Setting the Delphi Mechanical Injection Pump257
Adjusting the Mechanical Controls of the Delphi Injection Pump259
Fitting Delphi Diesel Injectors261
Injection Pump Specifications (Bosch and Siemens)262
Checks: Low Pressure Fuel Supply Circuit263
Checks: Turbo Pressure267
Checking te Air Supply Circuit272
Checks: Exhaust Gases Recycling Circuit274
Particle Filter Safety and Cleanliness Requirements277
Special Features: Forced Regeneration of the Particle Filter279
Special Features: Particle Filter/Filling of the Additive Reservoir280
Speedometer284
Clutch Specifications285
Clutch Controls: Features/Checks and Adjustments292
Clutch Controls: Features/Checks and Adjustments Hydraulique295
Gearbox and Tyre Specifications297
MA/5 Gearbox304
Recommendations - Precautions: MA Piloted Manual Gearbox312
MA/5 Piloted Manual Gearbox316
BE4/5 Gearbox321
MA/5 Gearbox Controls325
Checks and Adjustments: MA/5 Gearbox Controls326
BE4/5 Gearbox Controls329
Checks and Adjustments: Be4/5 Gearbox Controls330
Recommendations- Precautions: AL4 Automatic Gearbox336
AL4 Automatic Gearbox340
Draining/Filling/Top-Up: AL4 Gearbox355
Driveshafts - Gearbox358
Axle Geometry359
Axle Geometry360
Front Axle362
Rear Axle363
Suspension364
Features of Electric Power Steering365
Special Features: Steering368
Rear Damper396
Manual Steering Specifications397
Power-Assisted Steering Specifications400
Xsara Picasso404
Steering Column Specifications411
Brake Specifications (Without ABS)415
Brake Specifications (with ABS)416
Brake Specifications417
Brake Specifications422
Handbrake (Adjustment)423
Bleeding and Filling the Braking System425
Brake Specifications (Without ABS Ref)428
Brake Specifications (with ABS Ref)429
Handbrake454
Bleeding the Brakes455
Braking System Specifications458
Starter Motors463
Alternators476
Charging Circuit - Alternator with Mono-Function Regulator484
Pre-Heating and Starting Systems486
Air Conditioning R 134 a (HFC)487
Special Features: Air Conditioning System488
Checking the Efficiency of the Air Conditioning System503

CITROEN C2 2004 - Page 308

Table of Contents

Related product manuals