Waterside Care
3-8
750-368
CBEX Elite 100-1200 HP
Water Capacity and Weights
2. All valves in the piping leading to or from the system must be closed to prevent the cleaning solution from get-
ting into the system.
3. When dissolving chemicals:
A. Put warm water into a suitable container.
B. Slowly introduce the dry chemical into the water, stirring it at all times until the chemical is completely dis-
solved.
C. Add the chemical slowly and in small amounts to prevent excessive heat and turbulence.
4. Water relief valves and steam safety valves must be removed before adding the boilout solution so that neither
the boilout solution nor the grease the solution may carry will contaminate the valves. Use care in removing
and reinstalling the valves (refer to sections 1.4.3 and 8.15 for more on valve installation).
5. An overflow pipe should be attached ton one of the top boiler openings and routed to a safe point of dis-
charge. The safety valve tapping is usually used.
6. Fill the pressure vessel with clean water at ambient temperature until the top of the tubes are covered. Add
the cleaning solution, slowly and in small amounts, and then fill to the top with water.
7. The boiler should then be fired intermittently at a low rate sufficient to hold solution just at the boiling point.
Boil the water for at least five hours. Do not produce steam pressure.
8. Allow a small amount of fresh water to enter the boiler to create a slight overflow that will carry off surface
impurities.
9. Continue the boil and overflow process until the water clears. Shut the burner down.
10. Let the boiler cool to 120º F or less.
CBEX
Steam Hot Water
Lbs. Gal. Lbs. Gal.
100
6549 786 7185 863
125
6882 826 7549 906
150
8006 961 9102 1093
200
9062 1088 10314 1238
250
11618 1395 13755 1651
300
12188 1463 14419 1731
350
19340 2322 22499 2701
400
19647 2359 22942 2755
500
20059 2408 24975 2998
600
21619 2595 26884 3227
700
25051 3007 31731 3809
800
25868 3105 32741 3931
900
36000 4322 - -
1000
36500 4382 - -
1100
38000 4562 - -
1200
39000 4682 - -
To Next Page
Loading...
