EasyManua.ls Logo

CountyLine CL520CT7 - User Manual

CountyLine CL520CT7
28 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
5970 0309
CL520CT7
OWNER’S MANUAL
Convertible 1/2 HP Jet Pump/
Tank System
MANUAL DEL USUARIO
Sistema de tanque/bomba de
chorro convertible de 1/2 HP
©2017 CL934 (Rev. 06/15/17)
Installation/Operation/Parts
For further operating, installation,
or maintenance assistance:
Call 800-535-4950
English...........Pages 2-13
Instalación/Operación/Piezas
Para mayor información sobre el
funcionamiento, instalación o
mantenimiento de la bomba:
Llame al 800-535-4950
Español ....... Páginas 14-25
293 Wright Street, Delavan, WI 53115
Phone: 800-535-4950
Fax: 800-526-3757
www.tractorsupply.com

Table of Contents

Questions and Answers

  • M
    Michele GibbsAug 5, 2025
    How to troubleshoot CountyLine CL520CT7 Water Pump motor that will not run?
    • S
      Samantha ParsonsAug 5, 2025
      If the CountyLine Water Pump motor won't run, first, ensure the disconnect switch is on. If that's not the issue, check the fuse and replace it if blown, or reset the circuit breaker if it has tripped. Also, the starting switch may be defective and require replacement after you disconnect the power. Dirty pressure switch contacts can also be the reason; in that case, disconnect the power and file the contacts with an emery board or nail file. Finally, check and tighten all wiring, referring to the instructions in the Electric section, after disconnecting the power, to avoid electric shock.
  • M
    Monica RodgersAug 16, 2025
    What to do if CountyLine CL520CT7 Water Pump motor runs hot?
    • M
      Michael MorrisonAug 17, 2025
      If the CountyLine Water Pump motor runs hot and the overload kicks off, it could be due to several reasons. First, the motor might be wired incorrectly; refer to the wiring instructions. Second, the voltage might be too low; check with the power company and install heavier wiring if the wire size is too small, consulting the Wiring Chart. Finally, the pump might be cycling too frequently; consult the section on too frequent cycling.
  • L
    Leslie NelsonAug 29, 2025
    Why CountyLine Water Pump does not deliver water to full capacity?
    • U
      umatthewsAug 29, 2025
      If the CountyLine Water Pump does not deliver water to full capacity, it could be due to several reasons. The water level in the well might be lower than estimated, potentially requiring a new nozzle and venturi combination. Steel piping might be corroded or limed; replace it with plastic pipe where possible, or with new steel pipe. Additionally, the piping might be too small in size; use larger piping.
  • R
    Robert KnappNov 9, 2025
    Why does my CountyLine CL520CT7 Water Pump keep cycling on and off?
    • S
      Steven LeeNov 10, 2025
      If your CountyLine Water Pump delivers water but doesn't shut off or cycles too frequently, several issues could be the cause. Begin by checking if any faucets have been left open and close them. Inspect the pressure switch; it may be out of adjustment or have welded contacts, requiring you to disconnect the power to adjust or replace it. A waterlogged standard pressure tank lacking an air cushion can also cause this issue; drain the tank to the air volume control port. Also, check for leaks in the pipes and foot valve, and inspect the suction pipe for air leaks using soapy water to check joints. If the air charge is too low in the pre-charged tank, disconnect the power and open the faucets until all pressure is relieved. Lastly, a clogged venturi, nozzle, or impeller can be the reason; cl...
  • V
    Vanessa DiazNov 22, 2025
    Why is my CountyLine CL520CT7 running but not pumping water?
    • C
      cheyenne37Nov 22, 2025
      If the CountyLine Water Pump motor runs but no water is delivered, consider these possibilities: * If newly installed, the pump may not have picked up prime; re-prime it according to instructions. * The pump may have lost prime; check all connections on the suction line and shaft seal. * The foot valve or strainer could be plugged; clean them. * The ejector or impeller might be plugged; clean them as well. * A check valve or foot valve could be stuck shut; replace them if necessary. * Pipes might be frozen; thaw them, bury them below the frost line, or heat the pit or pump house. * The foot valve and/or strainer may be buried in sand or mud; raise them above the bottom of the water source and clean them. * The water level may be too low for a shallow well setup; if your w...

Summary

CountyLine 1;2 HP Jet Pump System: Overview & Support

Contact and Support Information

Company address, phone, fax, website, and customer service contact details.

Essential Safety Instructions and Warnings

General Safety Precautions & Electrical Hazards

Covers electrical, burn, explosion risks, and general handling safety advice.

California Proposition 65 Health Warning

Details chemicals known to cause cancer or reproductive harm in California.

CountyLine Pump Warranty Policy & Terms

Limited Warranty Coverage and Eligibility

Explains the 12-month warranty, eligibility, exclusions, and purchaser responsibilities.

General Warranty Terms and Remedies

Outlines limitations, remedies, and legal rights related to product defects.

Replacing Existing Convertible Pump

Deep Well Pump Replacement Guide

Step-by-step guide for replacing a deep well pump.

Shallow Well Convertible Pump Replacement

Instructions for replacing a convertible pump in a shallow well system.

New Shallow Well Convertible Pump Installation

Cased Well Installation Procedure

Details on installing a pump in a 2" or larger cased well.

Driven Point Installation Procedure

Steps for installing a pump using a driven point well system.

General Shallow Well Installation Tips

Tips on suction piping, fittings, and priming tee usage for shallow wells.

New Deep Well Convertible Pump Installation

4 Or Larger Deep Well Installation

Instructions for installing pumps in 4" or larger deep wells.

2 Deep Well Installation

Steps for installing pumps in 2" deep wells, including specific kit notes.

Electrical Wiring and Voltage Setup

Checking and Setting Pump Voltage

Guide to verifying and adjusting the pump's voltage setting (115V/230V).

Connecting Power Supply Wiring to Switch

Instructions for safely connecting power supply wires to the pressure switch.

Electrical Wiring Procedures & Specifications

Wiring Connections and Compliance

Details on wiring, grounding, code compliance, and motor voltage connection.

Recommended Wire and Fuse Sizes Chart

Chart specifying wire gauge and fuse ratings based on distance and motor specs.

Deep Well Pump Startup and Priming

Filling and Priming the Deep Well Pump

Steps to fill the pump and piping, and prime the system for deep well operation.

Setting the Control Valve for Efficiency

Guide to adjusting the control valve for optimal pump pressure and efficiency.

Shallow Well Pump Startup and Priming

Filling and Priming the Shallow Well Pump

Instructions for filling and priming the pump and piping for shallow well operation.

Pump Troubleshooting and Problem Solving

Common Pump Issues and Corrective Actions

Addresses common pump problems like motor issues, no water, and frequent cycling.

1;2 HP Convertible Pump Repair Parts

Pump Component Identification and Part Numbers

Diagrams and part numbers for motor, seals, impellers, and other pump components.

Repair Kits and Assemblies Listing

List of available repair kits, including seal, overhaul, and ejector kits with part numbers.

Additional Pump and Tank Repair Parts

Pump and Tank Part Numbers Listing

Part numbers for regulators, gauges, hoses, clamps, tank flange, and air valve.

CountyLine CL520CT7 Specifications

General IconGeneral
BrandCountyLine
ModelCL520CT7
CategoryWater Pump
LanguageEnglish

Related product manuals