Doosan Mega 500-V - MAINTENANCE INTERVALS

4-6 Inspection, Maintenance and Adjustment 022-00029AE Operation and Maintenance Manual
MAINTENANCE INTERVALS
10 HOUR / DAILY SERVICE
• Grease Front Attachment Pins (See page
4-8)*
• Inspect All Tires for Correct Tire Pressure
and Signs of Damage or Abnormal Wear
(See page 4-8)
• Check Engine Oil Level (See page 4-8)
• Check Transmission Oil Level (See page
4-9)
• Check Hydraulic System Oil Level (See
page 4-10)
• Check for Leaks in the Hydraulic System
(See page 4-11)
• Refill Fuel (See page 4-12)
• Check for Leaks in the Fuel System (See
page 4-12)
• Drain Fuel Condensation (See page 4-12)
• Check Coolant Level (See page 4-13)
• Check Antifreeze Protection Levels (See
page 4-14)
• Check Level of Window Washer Fluid (See
page 4-14)
• Inspect the Bucket Teeth and Side Cutters
for Signs of Wear (See page 4-14)
• Inspect Seat Belt for Proper Operation (See
page 4-14)
• Inspect the Structure for Cracks and Faulty
Welds (See page 4-14)
• Check the Operation of All Switches (See
page 4-15)
• Check the Operation of All Exterior Lights,
Horn and Control Console Indicator and
Monitor Lights (See page 4-15)
• Start Engine, Check Starting Ability, and
Observe Exhaust Color at Start-up and at
Normal Operating Temperature. Listen for
Any Abnormal Sounds (See page 4-15)
• Check Operation of All Controls (See page
4-15)
• Inspect Engine Fan Blade (See page 4-16)
• Check Engine Drive Belt Wear (See page
4-16)
• Check Air Intake System (See page 4-17)
• Check Crankcase Breather Tube (See
page 4-17)
50 HOUR / WEEKLY SERVICE
• Perform All 10 Hour / Daily Service Checks
(See page 4-18)
• Grease Front Attachment Pins (See page
4-18)
• Grease Steering Cylinder Rod and Base
Ends (See page 4-23)
• Grease Upper and Lower Center Pins (See
page 4-23)
• Change Engine Oil and Filter (Initial) (See
page 4-23)*
• Hydraulic Full Flow Filter Replacement
(Initial) (See page 4-24)*
• Check Water Pump Belt Tension -
Alternator, and Air Conditioner Belt (Initial)
(See page 4-24)*
• Clean Exterior of Radiator, Oil Cooler and
Air-conditioner Evaporator (See page 4-24)
* Break-In