EasyManua.ls Logo

DreamCast AURA36-CFB60 - User Manual

Default Icon
30 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
1
DreamCast
design and production
Match Lit Firepit with Standing Pilot
60k - 250k BTU with Safety Shut-off
Installation & Operation Manual
OUTDOOR DECORATIVE
GAS APPLIANCES
CERTIFIED FOR USA & CANADA
We recommend that our fire pits
be installed and serviced by
professionals that are certified in the
U.S. by NFI
(National Fireplace Institute)
The installer is responsible for using the correct fuel line sizing and/or regulation to provide
gas within the specified minimum and maximum gas inlet pressures of the fire feature.
⚠ WARNING
Do not store or use other flammable vapors and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
⚠ WARNING
Improper installation, adjustment, alteration, service or maintenance can cause injury or
property damage. Read the installation, operating and maintenance instructions thoroughly
before installing or servicing equipment.
Certified to
ANSI STD Z21.97 - 2017
CSA STD 2.41 - 2017
4011077

Table of Contents

Questions and Answers

  • M
    Michael MartinAug 7, 2025
    What to do if the DreamCast Outdoor Fireplace pilot will not light?
    • K
      kmathewsAug 7, 2025
      If the pilot light on your DreamCast Outdoor Fireplace won't ignite, there are several potential causes. First, ensure sufficient gas flow by checking that the main gas control valve and any secondary control valves are open. For LP systems, verify the propane tank isn't empty, inspect the regulator for damage or improper installation, and make sure the fire pit valve is OFF when the tank is turned ON, then turn the tank valve ON slowly. Air in the system can also prevent ignition, so allow a few minutes for the system to purge air. Also, you can adjust the pilot valve counterclockwise to increase gas flow to the pilot, keeping it at the minimum level required. If problems persist, the system may be incorrectly assembled or faulty, and you should consult a qualified technician.
  • D
    Danielle SchmidtAug 16, 2025
    What to do if the main burner of my DreamCast AURA36-CFB60 will not light?
    • A
      Allison RojasAug 17, 2025
      If the main burner on your DreamCast Outdoor Fireplace fails to light, check for media obstructions and rearrange the fire pit media to ensure a clear flow between the pilot and the nearest burner ports. Also, a weak pilot flame or insufficient gas flow could be the cause. See the sections about 'Insufficient Gas Flow To Pilot' and 'Insufficient Gas Flow' for solutions. If the problem persists, the system may be incorrectly assembled or faulty; in this case, consult a qualified technician.
  • Y
    ybakerAug 26, 2025
    Why one or more flame jets will not light on my DreamCast AURA36-CFB60?
    • S
      Samantha FigueroaAug 27, 2025
      If one or more flame jets on your DreamCast Outdoor Fireplace won't light, it's likely due to blocked jets. Clean the burner orifices and check the jets for any obstructions. Additionally, rearrange the fire pit media to ensure clear gas flow from the jets.

Summary

General Information and Safety

Carbon Monoxide Hazards

Discusses symptoms and risks of CO poisoning.

Natural Gas & Propane Information

Information on odorants and leak detection.

Warranty Requirements

Specifies covering the appliance when not in use.

Installation Location Considerations

Guidelines for high altitude and local codes.

Firepit Setup and Care

Unboxing and Initial Inspection

Instructions for checking and handling parts upon receipt.

Concrete Care and Maintenance

Guidance on maintaining the concrete finish and cleaning.

Firepit Installation and Leveling

Steps for positioning and leveling the fire pit.

Gas Inlet Pressures and Installation

Code and Pressure Requirements

Emphasizes installer's responsibility to consult local codes and pressures.

General Installation Steps

Detailed instructions for connecting gas lines, assembly, and leak testing.

Location Considerations

Fire Pit Clearance to Combustibles

Specifies required clearances from combustible materials.

Positioning Gas Supply

Gas Line Installation Guidelines

Instructions for routing gas lines for round and square fire pits.

Assembly Instructions Overview

Assembly Steps Sequence

Lists the sequence of steps for assembling the fire pit.

Detailed Assembly

Component Identification and Preparation

Locating and preparing components before assembly.

Burner and Pilot Assembly Mounting

Instructions for attaching the burner and pilot to the support plate.

Control Valve Assembly and Mounting

Steps for assembling and mounting the control valve.

Connecting Control Valve to Gas Supply

Instructions for connecting the control valve to the gas supply.

Final Assembly Connections and Testing

Connecting the control valve to the burner and performing leak tests.

Firepit Media Installation

Guidelines for properly placing decorative media around the burner.

Operating Instructions

General Operating Precautions

Important considerations before turning on the firepit.

Lighting the Pilot and Main Burner

Step-by-step guide to ignite the pilot and main burner safely.

Turning Off the Fire Pit

Procedure for safely shutting down the fire pit.

Troubleshooting Guide

Pilot Ignition Issues

Solutions for problems with the pilot light not igniting.

Main Burner Ignition Failures

Solutions for issues when the main burner fails to light.

Flame Jet Issues

Troubleshooting for blocked or unlit flame jets.

Flame and Noise Issues

Solutions for low flame, excessive soot, or noisy burner operation.

General Maintenance

Jet Orifice Cleaning

Annual cleaning of burner jets for optimal performance.

Pilot Assembly and Thermocouple Cleaning

Cleaning soot from pilot assembly and thermocouple.

Concrete Maintenance Reference

Referral to an online guide for concrete care.

DreamCast Limited Warranty

Warranty Terms and Limitations

Details exclusions and limitations of the product warranty.

Warranty Claim Procedures

Outlines the process for reporting and handling warranty claims.

DreamCast AURA36-CFB60 Specifications

General IconGeneral
ModelAURA36-CFB60
CategoryOutdoor Fireplace
Fuel TypeGas
Dimensions36-in
Ignition TypeElectronic
Warranty1 Year Limited Warranty

Related product manuals