iii
TABLE OF CONTENTS
GEOCENTER
Installation and Operation Manual
Section . . .
1.0 PREFACE ......................................................................................................... 1
2.0 INTRODUCTION ...............................................................................................
2
3.0 SPECIFICATIONS ............................................................................................ 3
3.1 Dimensions ...............................................................................................
3
3.2 Access Requirements ..............................................................................
3
3.3 Product Pickup and Discharge .................................................................
3
3.4 Electrical Requirements ...........................................................................
3
3.5 Plumbing Requirements ...........................................................................
4
3.6 Components Supplied ..............................................................................
4
3.7 Components Not Supplied .......................................................................
4
4.0 INSTALLATION PROCEDURES ...................................................................... 5
4.1 Pre-Planning the Installation ....................................................................
5
4.2 Installing the Transformer .........................................................................
5
4.3 Mounting the GeoCenter ..........................................................................
5
4.4 Mounting Sensor in Wash Tank ................................................................
5
4.5 Geosystem Detergent Dispenser Installation ...........................................
5
4.6 VANGUARD Wash Max Installation .........................................................
5
4.7 Geosystem Rinse Dispenser ....................................................................
6
4.8 Rinse Injector Connections ......................................................................
6
4.9 Hydraulic Connections and Visual Flow Indicator ....................................
6
5.0 ELECTRICAL CONNECTIONS ........................................................................ 7
5.1 Transformer Wiring ...................................................................................
7
5.2 440 Volt Machine Power Supply ...............................................................
8
5.3 S-2000 Sensor Wire Connections ............................................................
8
5.4 Geosystem Detergent Dispenser Wiring Connections .............................
8
5.5 Geosystem Solid Rinse Reservoir Connections .......................................
8
5.6 VANGUARD Wash Max Wiring Connections ...........................................
8
5.7 Two Pole Probe Wire Connections ...........................................................
8
6.0 SYSTEM ADJUSTMENTS ............................................................................... 9
6.1 Cell/Sensor Selection ...............................................................................
9
6.2 Concentration Adjustment ........................................................................
9
6.3 Feed Adjustment Potentiometers .............................................................
9
6.4 Sonalert
®
Volume Adjustment ................................................................. 10
6.5 Sonalert
®
Alarm Delay ............................................................................ 10
6.6 Rinse Speed Control ..............................................................................
10
6.7 Timed Feed ............................................................................................
10
6.8 Feed Delay .............................................................................................
10
To Next Page
Loading...