I–8
INDEX
Terminal Release Tool, P/N 351413 124
Test Propeller 10, 12
Thermal Joint Compound, P/N 322170 189
Tilt Cylinder End Cap Remover/Installer, P/
N 326485 350, 357
Tilt Cylinder Seal Protector, P/N 326005
352
Tilt Tube Service Kit, P/N 434523 262
Torquing Socket, P/N 346187 221, 235
Trim Cylinder End Cap Remover/Installer,
P/N 436710 353, 356
Trim/Tilt Service Kit, P/N 390010 340
Trim/Tilt Service Kit, P/N 434524 339
Universal Puller Set, P/N 378103 109
Universal Shift Rod Height Gauge, P/N
389997 293
Universal Spanner Wrench, P/N 912084
350, 353, 356, 357
Wrench Retainer, P/N 341438 296, 312
Wrist Pin Cone, P/N 331913 231
Wrist Pin Pressing Tool, P/N 396747 222
Wrist Pin Retaining Ring Driver, P/N
396747 231
Torque Charts
see Service Charts
TPS Calibration 68, 113
Trailering Bracket
Lubrication 36
Operation 331
Trim and Tilt
Circuits 105
Disassembly 347
Electrical Circuit Tests 105
Inspection 338
Installation 346
Lubrication 39
Manifold and Reservoir Installation 355
Manual Release 336
Pressure Leakdown Test 339
Removal 345
Reservoir Fluid 338
Troubleshooting 338
Trim and Tilt Motor
Current Draw Tests 342
Installation 357
No Load Test 343
Trim Gauge Test 344
Trim Rods
Assembly 354
Installation 356
Removal 353
Trim Sender
Adjustment 29
Test 344
Trim Tab
Adjustment 30
Installation 289
Removal 287
Troubleshooting
Charging System Tests 97
Cylinder Drop Tests 77
Diagnostic Procedures 74
Fuel Control Adjustment 77
Fuel System 139
Ignition 80, 83
Inductive Amp Meter Test 77
Oiling System 173
Outboard Excessive Smoking T–5
Outboard Hard to Start T–3
Outboard Starts and Stalls T–4
Outboard Starts, Low Maximum RPM T–5
Outboard Surges, Runs Rough T–6
Outboard Will Not Start T–1
Outboard Won’t Shut Off T–4
Strategy 76
Timing Light Test 77
Trim and Tilt 338
Trim Sender 344
Trouble Check Chart 1
U
Upper Mount
Installation 270, 272
Removal 266, 268
V
Vapor Separator
Description 135
Installation 146
Removal 146
Voltage Drop Test 102
To Next Page
Loading...
