GE TLE 160 User Manual

Critical Power
Modifications reserved
Page 5/91
GE_UPS_USM_TLE_SUL_M16_M50_2bU_V010.docx
User Manual TLE Series 160 - 500 UL S2B
Table of content Page
1 IMPORTANT SAFETY INSTRUCTIONS ................................................................................................................................ 6
2 LAYOUT .................................................................................................................................................................................. 9
2.1 LAYOUT TLE SERIES 160 - 220 - 225 - 250 ............................................................................................................................................................... 9
2.2 LAYOUT TLE SERIES 300 - 400 - 500 ........................................................................................................................................................................ 10
3 INTRODUCTION .................................................................................................................................................................11
4 DESCRIPTION......................................................................................................................................................................12
4.1 BLOCK DIAGRAM AND MAIN ELEMENTS ................................................................................................................................................................ 13
4.2 OPERATION MODES......................................................................................................................................................................................................... 14
4.2.1 Normal VFI Operation Mode (Voltage Frequency Independent)...................................................................................................................................... 14
4.2.2 eBoost™ Operation Mode (option) .................................................................................................................................................................................................. 14
4.2.3 Utility Failure Operation ....................................................................................................................................................................................................................... 15
4.2.4 Utility Recovery Operation .................................................................................................................................................................................................................. 15
4.2.5 Automatic Bypass ................................................................................................................................................................................................................................... 16
4.3 RPA PARALLEL SYSTEM OPERATION ........................................................................................................................................................................ 17
4.3.1 Introduction to the RPA Parallel System ...................................................................................................................................................................................... 17
4.3.2 Features of RPA Parallel System ...................................................................................................................................................................................................... 18
4.3.3 System control .......................................................................................................................................................................................................................................... 18
4.3.4 Synchronization ....................................................................................................................................................................................................................................... 18
4.3.5 Load sharing .............................................................................................................................................................................................................................................. 18
4.3.6 IEMi Operation Mode (option) ............................................................................................................................................................................................................ 19
4.4 UPS PARALLELED ON THE SAME BATTERY ............................................................................................................................................................ 20
4.5 SERVICE AND TECHNICAL SUPPORT ........................................................................................................................................................................ 21
4.6 WARRANTY ......................................................................................................................................................................................................................... 21
4.7 RECYCLING INSTRUCTIONS ......................................................................................................................................................................................... 22
5 CONTROL PANEL ...............................................................................................................................................................23
5.1 CONTROL PANEL .............................................................................................................................................................................................................. 23
6 LCD SCREEN .......................................................................................................................................................................24
6.1 HOME SCREEN ................................................................................................................................................................................................................... 24
6.1.1 Description of the selection keys .................................................................................................................................................................................................... 25
6.1.2 Description of the signaling LEDs ................................................................................................................................................................................................... 26
6.2 MEASURES ........................................................................................................................................................................................................................... 29
6.3 EVENTS ................................................................................................................................................................................................................................. 33
6.3.1 Events (alarms and messages) ......................................................................................................................................................................................................... 35
6.3.2 Alarms list .................................................................................................................................................................................................................................................... 35
6.3.3 Messages list ............................................................................................................................................................................................................................................. 40
6.4 SETUP .................................................................................................................................................................................................................................... 43
6.5 COMMANDS ........................................................................................................................................................................................................................ 49
6.6 RPA PARALLEL SYSTEM .................................................................................................................................................................................................. 53
7 OPERATION .........................................................................................................................................................................55
7.1 PROCEDURES FOR SINGLE TLE SERIES 160 - 500 .............................................................................................................................................. 56
7.1.1 Initial start-up of the TLE Series 160 - 500.................................................................................................................................................................................. 56
7.1.2 Complete UPS shut-down ................................................................................................................................................................................................................... 60
7.1.3 Restore to normal operation after “System shutdown” with Load not supplied .................................................................................................... 61
7.1.4 Restore to normal operation after “EPO - Emergency Power Off” with Load not supplied ............................................................................... 63
7.2 PROCEDURES SINGLE TLE SERIES 160 - 500 FUNCTIONING AS FREQUENCY CONVERTER ............................................................. 65
7.2.1 Initial Start-up of the TLE Series 160 - 500 as frequency converter .............................................................................................................................. 65
7.2.2 Complete shut-down of the TLE Series 160 - 500 as frequency converter ............................................................................................................... 69
7.2.3 Restore to normal operation after “System shutdown” with Load not supplied .................................................................................................... 70
7.2.4 Restore to normal operation after “EPO - Emergency Power Off” with Load not supplied ............................................................................... 72
7.3 PROCEDURES FOR TLE SERIES 160 - 500 PARALLEL SYSTEM ....................................................................................................................... 74
7.3.1 TLE Series 160 - 500 Parallel System start-up .......................................................................................................................................................................... 74
7.3.2 Separate a UPS unit from the Redundant Parallel System ................................................................................................................................................ 79
7.3.3 Reconnect a UPS unit to Redundant Parallel System ........................................................................................................................................................... 81
7.3.4 Complete Parallel System shut-down........................................................................................................................................................................................... 83
7.3.5 Restore to normal operation after “System shutdown” with Load not supplied .................................................................................................... 84
7.3.6 Restore to normal operation after “EPO - Emergency Power Off” with Load not supplied ............................................................................... 86
8 OPTIONS ..............................................................................................................................................................................88
8.1 CONNECTIVITY OPTIONS ............................................................................................................................................................................................... 88
8.2 OPTIONS IN UPS CABINET ............................................................................................................................................................................................ 88
9 MAINTENANCE ...................................................................................................................................................................89
9.1 MAINTENANCE .................................................................................................................................................................................................................. 89
9.1.1 Service check ............................................................................................................................................................................................................................................ 89
9.1.2 Fans and ventilation .............................................................................................................................................................................................................................. 89
9.1.3 Other components with limited lifetime ...................................................................................................................................................................................... 89
9.1.4 Battery .......................................................................................................................................................................................................................................................... 90
9.1.5 UPS room conditions and temperature ....................................................................................................................................................................................... 90
9.1.6 Preventive maintenance program ................................................................................................................................................................................................. 90
10 NOTES ..................................................................................................................................................................................91
10.1 NOTES FORM ...................................................................................................................................................................................................................... 91

GE TLE 160 Specifications

General

Brand	GE
Model	TLE 160
Category	UPS
Language	English