haTmed Q70B - Small Steam Sterilizer Maintenance; Cleaning of Loaded Items Prior to Sterilization; Cleaning and Maintenance

- 28 -
8 SmallSteamSterilizerMaintenance
8.1 Cleaningofloadeditemspriortosterilization

 Beforesterilization,theloadofhandpiecemustbethoroughlycleared.
 Dustandcontaminantsseparatedfromtheloadwillcauseblockageoffilters,valvesand
piping,therefore,thesterilizationloadwithoutcleaningisnotallowedtoenterthedevice
forsterilization.
 Followallregulationsforcleaning,disinfection,andsterilizationprovidedbythedevice
manufacturer.
8.2 Smallsteamsterilizermaintenance
8.2.1 Cleaningandmaintenance
Regularcleaningandmaintenancecaneffectivelyextendthelifeofthesterilizerandensureagoodworking
condition.
Maintenanceitem Maintenancecycle Specialtool Maintenanceoperation
Replacetheseal Sterilize1000times Openthedoorandcheckwhetherthesealis
deformedorwrinkle,etc.Ifitisdeformedor
wrinkled,itisrecommendedtoreplaceit.
Sealmaintenance 2weeks  Removetheseal.Pleaserinseitwithwater
and wipe it dry with a soft cloth.After that
replacethelid.
Note:Payattentiontotheinstallation
directionoftheseal(thenarrowsideis
closetothechambercoverandthewide
sideisclosetothechamber).
Doorlockmaintenance Sterilize1000times lubricatingoil Asmallamountoflubricatingoilissprayed
ontheleftsideofthelidthroughthehole(A
indicated),andtheoutersurfaceiswipedby
apapertowel.

Cleaning distilled water
tank
Sterilize300times
 Washitwithcleanwater.
Clean the filter at both
ends of cooling water
inletpipe.
Sterilize100times
 Unscrew the nut at both ends of the inlet
pipeandrinseitwithcleanwater.
A