Hisun HS 250UTV - Battery Troubleshooting; Vehicle Troubleshooting

Introduction HS 200UTV/HS 250UTV
1-57
been recharged.
 P o o r t e r m i n a l
c o n n e c t i o n
 Clean the terminal
and tighten
securely.
 Keep the terminal
clean and tight.
Apply grease and
treat with anti-corrosive.
 Battery life expired
 Replace new
battery
From beginning starter
does not function,and
lights soon become dim
 Insufficient
charging
 Charge battery
Insufficiently
 Battery must be
serviced properly
before initial use
When viewed from the
top of plates, look
whitish.
* Refillable type battery
only
 Battery was used
with an insufficient
amount of
electrolyte.
 Add distilled water
and charge the
battery.
 Regularly check the
electrolyte level.
 Battery was used
with too much
without recharging.
 Charge battery
Insufficiently
 Charge battery
properly
Recharging is impossible .
 Battery life expired.
 Replace battery.
Terminals are severely
corroded and heat up.
 Poor terminal
connection
 Clean the terminal
and tighten
securely.
 Keep the terminal
clean and tight.
Apply grease and
treat with anti-
corrosives.
Battery electrolyte level
drops rapidly.
* Refillable type battery
only
 There is a crack or
pin holes in the
electrolytic cells.
 Replace battery.
 Charging system
trouble.
 Consult your local
dealer.
 If you have any questions, consult your local dealer.
 The factory installed battery is non-refillable type.
VEHICLE TROUBLESHOOTING
Trouble
Cause
Countermeasure
Gearshift does not
move freely
 High idling speed of engine
 Replace throttle cable;
 Replace throttle petal
 Replace the throttle