Honda BF8D - TROUBLESHOOTING; Engine fails to start; Engine speed does not increase; Engine speed fluctuates or engine stalls

〈〉
〈〉
〈〉
138
Engine fails to start
Engine speed does not increase
Engine speed fluctuates or engine stalls
TROUBLESHOOTING15.
No fuel in tank.
Fuel line is flattened or
kinked.
Fill tank with fuel.
Check for excessively
bent or pinched fuel
line.
Fuel line is flattened or
kinked.
Fuel filter is clogged. Replace fuel filter.
Check for excessively
bent or pinched fuel
line.
Sparkplugisfouled.
Spark plug heat range is
incorrect.
Sparkpluggapis
incorrect.
Remove spark plug
and dry and clean it.
Replace with spark
plug of proper heat
range.
Adjust to proper gap.
Fuel line is flattened or
kinked.
Check for excessively
bent or pinched fuel
line.
Fuel filter is clogged. Replace fuel filter.
Engine oil level is low. Check engine oil and
add to specified level.
Unmatched propeller is
selected.
Consult with an
authorized Honda
outboard motor dealer.
Passengers are not
distributed equally.
Distribute the
passengers equally.
Outboard motor is not
installed properly.
Install the outboard
motor in the proper
position.
Battery is discharged. Charge battery.
Fuel is contaminated or
stale.
Replace with new fuel.
Fuel connector is not
connected properly.
Connect properly.
Battery terminal is loose.
Spark plug cap is loose
or disconnected.
Tighten battery
terminal.
Install and tighten
spark plug cap
securely.
Fuse is blown out. Replace with new
fuse.
Engine is started in
wrong procedure.
Start in correct
procedure.
Fuel level is low. Add fuel.
1.
2.
3.
4.
5.
6.
7.
8.
9.
1.
2.
3.
4.
5.
6.
1.
2.
3.
4.
5.
6.
(Electric starter type)
(Electric starter type)
(Electric starter type)
11/09/05 18:19:53 32ZY0620_138