Jetmaster 18f - Default Chapter; Table of Contents

Contents
Installer Details .................................................................................................................................................................... 4
Installation Data Table and Dimensions ............................................................................................................................ 5
INSTALLATION INSTRUCTIONS
Introduction
Dimensions ............................................................................................................................................................................ 6
Regulations............................................................................................................................................................................ 6
Important Points To Note Before Starting Installation ............................................................................................................ 7
Paint ...................................................................................................................................................................................... 7
Installation Requirements................................................................................................................................................... 7
Unpacking.............................................................................................................................................................................. 7
Chimneys and Flues .............................................................................................................................................................. 8
Soundness of Flue................................................................................................................................................................. 8
Flue Size/Dimensions ............................................................................................................................................................ 8
Use of Existing Chimneys...................................................................................................................................................... 8
Termination ............................................................................................................................................................................ 9
Register Plates ...................................................................................................................................................................... 9
Bends .................................................................................................................................................................................... 9
Sweeping ............................................................................................................................................................................... 9
Flue Adaptor .......................................................................................................................................................................... 9
Hearths, Fire Surrounds and Shelves ................................................................................................................................... 9
Hearths .................................................................................................................................................................................. 9
Protection of Heat ................................................................................................................................................................ 10
Additional Protection of Heat ............................................................................................................................................... 10
Plastering............................................................................................................................................................................. 10
Air Supply ............................................................................................................................................................................ 11
Air Supplied from Room ...................................................................................................................................................... 11
Air Supplied from External Source ...................................................................................................................................... 11
Fitting the Fire .................................................................................................................................................................... 12
Site Preparation for Fitting ................................................................................................................................................... 12
Builders Opening ................................................................................................................................................................. 12
Inglenook Installations or Freestanding ............................................................................................................................... 12
Appliance Preparation ......................................................................................................................................................... 12
Door Removal...................................................................................................................................................................... 12
Tertiary Air Tubes ................................................................................................................................................................. 13
TertiaryAirTubeRemovalandLowerBafeRemoval ........................................................................................................ 13
UpperBafeRemoval ......................................................................................................................................................... 14
Internal Board Removal (Bottom, Rear and Sides) ............................................................................................................. 15
Ash Pan Removal ................................................................................................................................................................ 15
Bottom Board Grate Removal ............................................................................................................................................. 16
Rear Board Removal ........................................................................................................................................................... 16
Side Board Removal............................................................................................................................................................ 16
Log Attachment ( Log Box Attachment) ............................................................................................................................... 17
External Air Supply Fitting ................................................................................................................................................... 17
Flue Adaptor Connection to Fire .......................................................................................................................................... 17
RettingtheInternalComponents ....................................................................................................................................... 17
Fitting the Log Retainer ....................................................................................................................................................... 18
Fitting the Ash Pan .............................................................................................................................................................. 18
Fitting the Rear Heat Shield (Optional extra)....................................................................................................................... 18
Protection of Heat ................................................................................................................................................................ 19
Commissioning
After installation is complete ................................................................................................................................................ 20
Door Tension Adjustment ..................................................................................................................................................... 20
Air Supply ............................................................................................................................................................................ 20
Smoke Draw Test ................................................................................................................................................................ 20
TrimmingtheUpperandLowerBafes ............................................................................................................................... 21
Page